Abstract:Polyvinylidene fluoride (PVDF)–perfluorosulfonic acid (PFSA) blend hollow fiber ultrafiltration (UF) membranes were prepared by wet-spinning method using pure water as an external coagulation solution. Coagulation kinetics of PVDF–PFSA–DMAc system was measured by light transmittance experiment. Using PEG10000 (Mw=10,000), lysozyme (Mw=14,400), PEG20000 (Mw=20,000) and BSA (Mw=67,000), the separation performances of PVDF–PFSA blend hollow fiber UF membranes were obtained. Based on the experimental results, the delayed demixing process was observed for the dope solution M-1 without PFSA-H while the instantaneous demixing process was observed for the others with PFSA-H in the dope solutions M-2 to M-6. The precipitation rate increased with the increment of the PFSA-H concentration in PVDF–PFSA dope solution. The bore fluid solution with 95:5 DMAc:H2O resulted in single finger-like voids for PVDF–PFSA-H UF membrane. The pure water permeation flux of PVDF–PFSA-H UF membranes firstly increased from <0.1×10−5 to 119.1×10−5Lm−2h−1Pa−1 (<0.1 to 119.1Lm−2h−1bar−1) for M-1 to M-4(1) and 137×10−5Lm−2h−1Pa−1 (137Lm−2h−1bar−1) for M-4(2), and decreased from 119.1×10−5 to 79×10−5Lm−2h−1Pa−1 (119.1 to 79Lm−2h−1bar−1) for M-4(1), M-5 and M-6 as the PFSA-H concentration changed from 0% to 5% and total PVDF–PFSA-H concentration was 20wt.%. The molecular weight cut-off (MWCO) of PVDF–PFSA blend hollow fiber UF membranes spun from 20wt.% PVDF–PFSA-H concentration with 3–5wt.% PFSA-H was about 20,000 while that spun from 22wt.% PVDF–PFSA-H or PVDF–PFSA-Na concentration with 5wt.% PFSA-H or PFSA-Na was about 10,000. As the WPFSA-H/WPVDF increases from 2/18 to 5/15 for M-3–M-6, JBSA/Jw increases from 0.53 to 0.79. The anti-fouling property of PVDF–PFSA-H blend UF membrane is superior to PVDF–PFSA-Na blend membrane. Based on FTIR spectra, PFSA-H existed in PVDF–PFSA blend hollow fiber UF membranes. There is no obvious variation of the intensity of the characteristic peak at 983cm−1 assigned to C–O–C group of PFSA-H molecules. This also illustrated that PVDF–PFSA-H blend hollow fiber UF membranes were stable.

Preparation and performance of PSf-CA hollow fiber hemodialysis blend membrane

Polyelectrolyte membranes prepared by dynamic self-assembly of poly (4-styrenesulfonic acid-co-maleic acid) sodium salt (PSSMA) for nanofiltration (I)

Study on the Preparation of Hollow Fiber Ultra-filtration Membrane of PSF-SPES Blend

Fabrication of Hydrophilic and Sponge-Like PVDF/brush-like Copolymer Blend Membranes Using Triethylphosphate As Solvent

Preparation and Performance of Polyethersulfone Hollow-Fiber Membrane

Preparation and Properties of Functionalized Carbon Nanotube/psf Blend Ultrafiltration Membranes

Dialysis treatment, in vitro, and anticoagulation activity of polysulfone-polyacrylamide based-blend membranes: an experimental study

Preparation of PAN/PS blend ultrafiltration membrane and its performance

Preparation and characterization of PES/CA microporous membranes via reverse thermally induced phase separation process

The Preparation and Characterization of Novel Charged Polyacrylonitrile/pes-C Blend Membranes Used for Ultrafiltration

Study on the preparation of PDMS/PSF hollow fiber composite pervaporation membrane

Preparation and performance study of heparinized multi‐walled carbon nanotube/cellulose acetate hemodialysis membrane

Preparation and Characterization of PSf Hollow Fiber Membrane from PSf–HBPE–PEG400–NMP Dope Solution

Preparation and characterization of PVDF–PFSA blend hollow fiber UF membrane

Morphology and Performance of Polyvinylidene Fluoride/Perfluorosulphonic Acid Hollow Fibre Ultrafiltration Blend Membranes

Elution-free hollow-fiber membranes of block copolymers for hemodialysis balancing protein retaining and toxin clearance

Development Of A High-Performance Polysulfone Hybrid Ultrafiltration Membrane Using Hydrophilic Polymer-Functionalized Mesoporous Sba-15 As Filler

Preparation of polysulfone/sulfonated polysulfone-SiO 2 nanofiltration membrane and its performance characterization

Preparation of Antifouling Ultrafiltration Membranes from Copolymers of Polysulfone and Zwitterionic Poly(arylene Ether Sulfone)s

Preparation of Porous Diffusion Dialysis Membranes by Functionalization of Polysulfone for Acid Recovery

Enhancing the properties and performance of polysulfone ultrafiltration membranes using citric acid based deep eutectic solvent additives