Abstract:A combined steady-state and transient approach is employed to investigate the corrosion behavior of X80 pipeline steel in carbon dioxide-saturated brines. Continuous bubbling of carbon dioxide into a test vessel with 1 liter capacity is performed to simulate the flowing condition. The measurement of time-dependent open-circuit potential, polarization resistance, and electrochemical impedance spectroscopy (EIS) is conducted to interpret the evolution of dissolution processes at the corroding interface. Three distinguishing stages are observed at a temperature of 60 °C during a whole exposure of 144 h. Analyses mainly based on the consecutive mechanism show that after the first stage of the active-adsorption state, the anodic reaction is significantly retarded by the accumulation of (FeOH)ads on the iron surface, causing a sharp increase in the polarization resistance and the open-circuit potential, as well as the disappearance of the inductive loop in EIS. At the third stage, the formation of the corrosion product layer similarly reduces both the anodic and cathodic reactions, which arouses a linear increase in the polarization resistance with time and a capacitive loop in EIS but changes the open-circuit potential slightly. An increase in salinity in this study reduces the polarization resistance and enhances iron dissolution by promoting the formation and relaxation of (FeOH)ads; however, it brings little change to the developing time of the three stages obviously. At a low temperature of 20 °C, a protective product layer is not observed in carbon dioxide-saturated brine, and the dissolution of iron is mainly under activation control during the whole exposure. A notable enlarged polarization resistance and different interfacial processes are observed in an alkaline solution compared with those in acidic environments, which is deduced to be resulted from an impedance in the relaxation of (FeOH)ads by increasing pH. The observations in this study support well that the iron dissolution reaction at the initial stage exposed in carbon dioxide aqueous environments is dominant by water adsorption on the iron surface, and further investigation should be performed on the role that carbon dioxide plays in the evolution of corrosion products and the formation of a protective film on the steel surface by taking into account local water chemistry.

Corrosion Behavior and Mechanism Research of X80 Pipeline Steel in Simulated Solution of Lianmuqin Soil

Corrosion Behaviors and Mechanical Properties of Q235 Steel Pipes Collapsing Due to Corrosion after 25-Year Service in Urban Industrial Atmospheric Environment

Corrosion behavior of the weld joint of X80 pipeline steel in an acidic red soil

Corrosion Behavior of X80 Steel in a Simulated Soil Solution Under Square-Wave Current Interference

Corrosion behaviour of X80 pipeline steel welded joint in H2O- saturated supercritical-CO2 environment

Experimental Investigation on Corrosion Behavior of X80 Pipeline Steel under Carbon Dioxide Aqueous Conditions

Corrosion characteristics of simulated reheated heat-affected-zone of X80 pipeline steel in carbonate/bicarbonate solution

Anodic Dissolution Characteristics of the X80 Pipeline Steel in Simulated Soil Solution

CO2 corrosion behavior of simulated heat-affected zones for X80 pipeline steel

Study on accelerated corrosion behavior and mechanism of X80 pipeline steel welded joint under cyclic salt spray test

Technical Note: Study on Accelerated Corrosion Behavior and Mechanism of X80 Pipeline Steel Welded Joint under Cyclic Salt Spray Test

Corrosion behavior of X80 pipeline steel local defect pits under static liquid film

The corrosion behavior and cracking susceptibility of the disbonded coating in the X80 steel pipeline by theoretical simulations and experimental measurements

Insight into sulfate-reducing bacteria corrosion behavior of X80 pipeline steel welded joint in a soil solution

Blunt and penetrating trauma--has anything changed?

STUDY ON THE ACCELERATED CORROSION BEHAVIOR OF A GALVANIZED X80 PIPELINE STEEL WELDED JOINT DURING A CYCLIC SALT SPRAY TEST

Research on the Corrosion Behavior of Q235 Pipeline Steel in an Atmospheric Environment through Experiment

ELECTROCHEMICAL CHARACTERISTICS OF X70 PIPELINE STEEL IN A SYNTHETIC NEAR NEUTRAL SOIL SOLUTION

Study on Corrosion Behavior of X80 Pipeline Steel in 5%NaCl+0.5% Acetum

Electrochemical and Mechanical Properties of Cathodically Protected X80 Steel in Different Temperature Soil

Microbial corrosion behavior of pipeline steels in simulation environment of natural gas transportation pipeline