Abstract:Objective The design technique for 64 channels ultrahigh-speed synchronous transient testing system with data sampling frequency of 2 MHz-10 MHz was researched, in order to realize the design of hardware architecture and software architecture for two kinds of typical ultrahigh-speed transient testing systems. Methods For hardware architecture, the continuous high-speed test system with continuous flow disk storage constructed based on PXI-Express bus data transmission and RAID array stream disk data saving and the high-speed test system constructed based on large capacity on-board cache data saving and bus downloading transmission were applied in detail. For high-performance system software design, the design technique with application of producer/consumer architecture and finite state machine was applied. Results Currently, for system with 64 channels, the data sampling frequency could only reach 2.5 MHz with the limitation of file writing speed based on PXI Express bus and raid array stream disk data saving architecture, while the data sampling frequency could reach 10 MHz based on architecture with on-board cache data and PXI bus downloading data, in this condition, the test time of the system could reach 5 s. Conclusion These two kinds of test systems could both meet the requirements of ultrahigh-speed transient test, and the system architecture could be decided by the maximum sampling frequency required.

Research on the Software and Hardware Architecture Design Technique for Ultrahigh-speed Transient Testing System

An Automatic Test System for a Spaceborne Chip of a Temperature-Sensing Controller

Design and FPGA Verification of a Novel Reliable Real-Time Data Transfer System

Design and Implementation of a High-Speed Sonar Data Transmission System

FPGA Implementation of High-Speed Data Acquisition System for High-Resolution Millimeter Wave Radar.

Design of High-Speed Data Transmission System for IC Test

Logical Architecture Design of Integrated Electronic System with High Real-Time and Reliability in ZDPS-2 Pico-Satellite

Design for HW/SW Co-Testing Based on FPGA

DMA-based High-Speed Parallel Acquisition System of Digital Signals

Research of a New High-Performance Data-Collecting Transmissive System

Design of High-Speed Multi-Channel Data Acquisition System Based on Virtual Instrument Technology

Design and Implementation of FPGA Based High-Speed Bus for Control System

The Ultrasonic Testing System with PCI Bus Based Four-Channel Data Acquisition Card for Train Axles

Data acquisition system design of high-speed ECT system

6-Channel High-speed Parallel Data Acquisition Card for Ultrasonic Signal Based on PCI Bus

The Hardware Measurement System for High-Speed Network Flow

High-Speed Low-Noise Test System For Irfpa

A PXI-based, Multi-channel Ultra-fast Data Acquisition System for Transient Pulsed Signals

Design of High-speed Data Transmission System based on PCI Express interface

Design and Implementation of High Performance DAQ System for IRFPA Testing

Design of High-Speed ECT and ERT System