Abstract:Inefficient conversion of structure-complicated and oxygen-enriched asphaltenes is found as the major challenge facing coal tar in achieving high value-added utilization. Hydrogenation technology is the primary way to achieve the impurity removal and lightweight of coal tar asphaltenes (CTAS). In this study, the evolution laws of functional groups and structural parameters at different reaction times, and pyrolysis behavior at different temperatures of coal tar asphaltenes (CTAS) during the hydrotreating (HDT) process were investigated using the methods of FT-IR, XPS, 1 H-NMR, 13 C-NMR and Py-GC/MS. It was found that the increase of the reaction time significantly affected CTAS hydrodeoxygenation (HDO), and most of nitrogen-containing compounds (NCs) and sulfur-containing compounds (SCs) could be removed in a shorter reaction time. However, the increase of the reaction time has a limited effect on the removal of NCs and SCs embedded in polycyclic aromatic compounds. The average alkyl chain length ( L ) decreased with the increase of the reaction time, and the degree of branching for alkyl side chains ( B ) increased after HDT. The aromatic ring substitution degree (σ) and alkyl substituents number ( n ) of CTAS increased after HDT. The OH-OH and OH-ether O were found as the major hydrogen bonds in asphaltene feed (Asp-feed) and asphaltene product (Asp-product), followed by OH-π and cyclic OH. With the increase of reaction time, the molar fraction of the OH-ether O hydrogen bonds increased, while OH-π hydrogen bonds decreased. C-O group was found as the critical oxygen-containing functional group in Asp-feed and Asp-product, primarily existing in the form of aromatic ether groups and C-O of phenols. With the increase of reaction time, the molar fraction of aromatic ether groups in CTAS increased significantly, while that of the C-O of phenols decreased. The pyrolysis fragments of Asp-feed and Asp-product were largely 1-3 ring aromatic hydrocarbons or heteroatoms compounds. Heteroatoms compounds primarily consisted of phenols and furans, whose alkyl side chains were short and few, mainly existing in the form of multiple methyl groups. The Asp-product produced smaller aromatic ring fragments, more aromatic hydrocarbons and less phenolic and non-phenolic oxygenated compounds than Asp-feed at the same pyrolysis temperatures

Influence of phenolics on hydrodenitrogenation, hydrodesulfurization and hyrodearomatization of coal tar components

Inhibiting effects of nitrogen compounds on deep hydrodesulfurization of straight-run gas oil over a NiW/Al2O3 catalyst

Mild Hydrotreatment of Low Temperature Coal Tar Distillate: Product Composition

N-N self-inhibition effect of aromatic N-heterocyclic compounds on NiWS supported γ-Al 2 O 3 hydrotreating catalyst

Insight into the hydrodenitrogenation mechanism of quinoline on the MoP(010) surface with and without the effect of sulfur

Catalytic o-methylation of phenols and its application in converting crude phenols in a low-temperature coal tar to mesitol and durenol

Hydrogenation of coal tar on NiMoP/γ-Al2 O3 catalyst

Hydrogenation of Model Compounds Catalyzed by Mcm-41-Supported Nickel Phosphide

Selective catalytic hydroconversion of a low-temperature coal tar-derived crude phenols to cyclohexanol over a nitrogen-doped Co-based catalyst

Probing the influence of hydrogen cyanide on PAH chemistry

A preliminary study on the co-hydrogenation process of coal tar and bio-oil

Tracing the Composition and Structure Evolution of Oxygen-enriched Asphaltenes During the Hydrotreating of Middle-low Temperature Coal Tar

Effect of Hydrogen Donor and Precursor of Donor on Catalytic Hydro-Cracking Reaction of Residue Oil

Preparation of Co-Mo/γ-Al2O3 catalyst and the catalytic hydrogenation effects on coal-related model compounds

Selective catalytic hydroconversion of crude phenols to cyclohexanols over a carbon-based nickel catalyst and separation of condensed arenes from a low-temperature coal tar

Reaction laws of polycyclic aromatic hydrocarbons and heteroatomic compounds in hydrocracking process

Insights into evolution mechanism of PAHs in coal thermal conversion: A combined experimental and DFT study

Hydrodeoxygenation of m-cresol as a depolymerized lignin probe molecule: Synergistic effect of NiCo supported alloys

Insight into asphaltene transformation during coal tar hydrotreatment by conventional analysis and high-resolution Fourier transform mass spectrometry coupled with collision-induced dissociation technology

Investigation on asphaltene compositions and structures during hydroprocessing of low-temperature coal tar at different reaction temperatures on Ni–Mo–W/γ–Al2O3 catalysts

Influence Of Feed Contamination On The Conversion Of Heavy Reformate And Toluene Mixture Over Composite Hierarchical Zeolite Catalyst