Abstract:In order to solve the problems of lower heating rate of the primary air/fuel mixture and higher NOx emission of the boiler, both the small-scale cold air experiment of a single burner and industrial-scale experiments of the centrally fuel-rich (CFR) swirl burner on a retrofitted 300 MW wall-fired boiler fed with low-volatile coal under deep air staging were performed. The aerodynamic characteristics, flue gas temperature, and temperature distribution of the furnace and carbon content in the fly ash were measured at loads of 300, 230, and 150 MW. Results illustrate that a central recirculation zone appeared close to the outlet the CFR burner under deep air staging. Compared with the enhanced ignition-dual register (EI-DR) burner, the gas temperature and the heating rate of the CFR burner are much higher, so it can guarantee the timely ignition and stable combustion of the pulverized coal. As for the CFR burner, with a decreasing load, the heating rate of the gas temperature decreases and the ignition position of the primary coal/air mixture becomes backward. The overall temperature of the furnace also decreases with decreasing load, as does the difference between the temperatures in the burning region and the lower position of the burnout region. After the retrofitting of the combustion system, the exhaust gas temperature decreases from 149 to 146 degrees C, the NOx emissions at the air preheater exits decrease from 1354 to 778 mg/m(3) ( 6 % O-2), and the boiler thermal efficiency increases from 89.75 to 90.57 % at the rated load.

Experimental Research of Low NOx Emission Combustion Technology and Combustion Optimization

Experimental Study on a 200MW Boiler Retrofitted With Low NOx Combustion System

Low NOx Combustion Technology for Coal-fired Boiler and Experimental Research

Study on Low NOx Optimimal Operation of a Tangentially Fired Boiler under Variable Parameters

An Experimental Research on Boiler Combustion Performance

Experimental Investigation of Operating Strategy of Low NOx, High Efficiency Coal-Fired Utility Boilers

E306 EXPERIMENTAL STUDY ON PERFORMANCE OF COMBUSTION AND NO EMISSION FOR LOW VOLATILIZATION COALS

Experimental Study of the Effect of Boiler Combustion Control on NOx Emission and Boiler Efficiency

Experimental Research on the Combustion and NO_x Generation Characteristics of Low Volatile Coal

Experimental study on combustion and NOx emission characteristics of Zhehun blended coal

An Experiment and Analysis for a Boiler Combustion Optimization on Efficiency and NO_x Emissions

Experimental study on low NOx combustion technology of pulverized coal

ICOPE-15-C042 130t/h Coal-fired boiler low NOx transformation and numerical simulation

Study on Low-NOx Emission of Lignite-Blended Burning Technology in the Bin and Feeder Coal Pulverizing System

Investigations on combustion optimization and NOX reduction of a 600-MWe down-fired boiler: Influence of rearrangement of tertiary air and jet angle of secondary air and separated over-fire air

Uitra Low NOx Emission Control of Utility Boiler with High Combusting Efficiency

Airflow And Combustion Characteristics And Nox Formation Of The Low-Volatile Coal-Fired Utility Boiler At Different Loads

Experimental characterization of anthracite combustion and NO emission for a 300-MWe down-fired boiler with a novel combustion system: Influence of primary and vent air distributions

Combustion Technologies of Down-fired Boilers with High Efficiency and Low-NO_x Emissions

Experimental of Effects of Boiler Structures and Burner Models on NOx Emission from Coal-Fired Boiler

Reducing NOx Emissions of an Opposed Swirling Coal-Fired Utility Boiler by Optimizing In-Service Burner Mode