Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Experimental Investigation of Boiling of Droplets on Heated Surfaces

Experiment for influence of boiling surface on critical heat flux in liquid nitrogen pool boiling

Experimental Investigation of Dynamic Evaporation Characteristics of Liquid Droplet on Heated Surface

Evaporation And Nucleate Boiling Of An Individual Droplet On Surfaces

Inner Phase Change Behavior of Small Liquid Droplet on Heated Solid Surface

Droplet boiling on heated surfaces with various wettabilities

Droplet Evaporation to Boiling in Van Der Waals Fluid

Visualization and quantitative study on film boiling heat transfer of a salt droplet on the hydrophobic substrate

An Experiment Study on Flash Boiling Spray

Study of the Natural Circulation Flow Boiling Heat Transfer Based On Partially Superhydrophilic Surface Modification

An Experimental Investigation on Spreading of Droplets with Evaporation and Nucleation

Impact and boiling characteristics of a droplet on heated surfaces: A 3D lattice Boltzmann study

Spreading of Droplets with Evaporation and Nucleation on Solid Surfaces

Multiphase SPH Modeling of Water Boiling on Hydrophilic and Hydrophobic Surfaces

Experimental Study of a Micrometer-Sized Droplet Impinging on a Smooth Heated Surface

Interfacial heat transfer and boiling transition of the droplets on superheated surface with Leidenfrost effects

Boiling evaporation characteristics of sessile droplets and its transition evaporation mode

Experimental study of two-phase heat transfer of droplet impact on liquid film

Regulated Transient Pool Boiling of Water During Quenching on Nanostructured Surfaces with Modified Wettability from Superhydrophilic to Superhydrophobic

Evaporation and explosion of liquid drops on a heated surface

Machine-assisted quantification of droplet boiling upon multiple solid materials