Abstract:In the present study, water-oil flow patterns and slug hydrodynamics were experimentally studied in square glass microchannels with various hydraulic diameters (Dh = 600 μm, 400 μm, 200 μm). The aqueous phase is the continuous phase while the organic phase is the dispersed phase. The ranges of flow rates of the continuous phase and the dispersed phase are 0–200 ml/h and 0–12 ml/h, 0–120 ml/h and 0–6 ml/h, and 0–60 ml/h and 0–2 ml/h in the microchannels with Dh = 600 μm, 400 μm and 200 μm, respectively. The results show that the hydraulic diameter has significant effects on flow patterns and three main flow patterns are observed, i.e., annular flow, slug flow and droplet flow. Generally, annular flow appeared at high flow rates of the dispersed phase and low flow rates of the continuous phase, while droplet flow appeared at low flow rates of the dispersed phase and high flow rates of the continuous phase. However, slug flow existed at comparable flow rates of the continuous and dispersed phases. A dimensionless analysis is carried out and a new dimensionless group including Weber number and Reynolds number is derived. The new defined dimensionless group performs well to develop a general flow pattern map. In addition, slug flow hydrodynamics are investigated as well in the present study, considering the slug length and slug velocity. Based on the present experimental results, a new scaling law is proposed to predict the slug length and it shows a good agreement with the experimental results. It has been widely reported that slug velocities depend linearly on the total flow rates of the two phases, which is consistent with the present study. The linear law provides a good prediction of the experimental slug velocities but different slopes are suggested in microchannels with different hydraulic diameters.

Influence factors on Poiseuille number of oil-water two-phase flow in microchannels

WATER-OIL FLOW IN SQUARE MICROCHANNELS WITH A CROSSED JUNCTION

Experimental Study on Resistance Characteristics of Oil-Water Two-Phase Flow in Channels with Micron Dimension

EFFECTS OF INLET ARRANGEMENTS ON LIQUID-LIQUID FLOW PATTERNS IN CROSS-JUNCTION SQUARE MICROCHANNELS

PRESSURE FLUCTUATIONS OF LIQUID-LIQUID SLUG FLOW IN CROSS-JUNCTION SQUARE MICROCHANNELS

Simulation of gas flow and heat transfer in micro Poiseuille flow

Experimental Study of Loss coefficients for Laminar Oil-Water Two-Phase Flow through Micro-Scale Flow Restrictions

Oil-Water Two-Phase Flow in a Horizontal Microchannel: Pressure Drop and Flow Pattern

Numerical Investigation on Flow Pattern of Air-Oil with Different Viscosities Lubrication

Friction Factor And Heat Transfer Of Nanofluids Containing Cylindrical Nanoparticles In Laminar Pipe Flow

Oil-Water Two-Phase Flow with Three Different Crude Oils: Flow Structure, Droplet Size and Viscosity

Oil–water two‐phase flow in microchannels: Flow patterns and pressure drop measurements

Experimental Study on Flow Characteristics in Rectangular and Circular Microchannels

Single-phase flow and heat transfer in micro-channels

Research on Flow Characteristics of Air-oil Two Phase Annular Flow for Oil-air Lubrication

Experimental investigation of flow characteristics for oil-water emulsions in horizontal tube

Effect of surface properties on the flow characteristics and mass transfer performance in microchannels

Characteristics of Liquid Flow in Microchannels at Very Low Reynolds Numbers

Research on inflow at low Reynolds number in square section straight Micro-channel

Flow Pattern Study and Pressure Drop Prediction of Two-Phase Boiling Process in Different Surface Wettability Microchannel

Visualization Study of Flow Boiling Characteristics in Open Microchannels with Different Wettability