Abstract:A new process by combining tubular reactor with reactive distillation column for synthesizing ethanolamine from ethylene oxide(EO) and ammonia was presented.This process used ammonia with a concentration of 90%and a ratio of ammonia to ethylene oxide 10/1 as feed conditions. Firstly,a tubular reactor was used to produce mixed products of ethanolamine from resultants with the reaction conditions of pressure 3 MPa and temperature(323~343) K.The mixture produced was then separated in flash drums and stripping column in order to remove the excessive ammonia. Finally,the mixture reacted together with another stream of ethylene oxide was fed into a reactive distillation column where the chemical reaction and products separation were carried out simultaneously.Simulations based on Aspen Plus simulation package were performed to investigate the feasibility and to identify suitable process conditions.Through simulation,the suitable process parameters in reactive distillation column were obtained as:operating pressure 0.05 MPa,the number of stages 10,the mole ratio of the ethylene oxide to ethanolamines 1/1,boilup ratio 8,and the typically profiles of the temperature and compositions were also provided.The simulation results showed that under the determined conditions,the key component EO and ethanolamine could be converted completely in the reaction distillation column,the water played a role both as catalyst and heat removing agent and recovered from distillate of the column,and the heavy components diethanolamine and triethanolamine were obtained from bottom products of the column.The results showed that the heat released by exothermic reaction can be directly utilized by distillation,and a selectivity of 75%toward the desired product diethanolamine could be achieved,which indicate,both in technical and economic aspects,the potential advantages of the process suggested in this work.

Synthesis and Process Development of N,N-Dialkylethanolamine

Study on the Synthesis of N-Ethylethylenediamine

Research on a New 2-(2-Dimethylaminoethoxy) Ethanol Synthesizing Process

A new process for synthesizing ethanolamine from ethylene oxide and ammonia and process simulation

Optimization of Synthetic Process of Triethyl 1, 1, 2-Ethanetricarboxylate

Study on synthesis of N-(β-hydroxypropyl)-ethylene diamine

Optimization of Synthetical Technology for Trimethylolpropane Diallyl Ether by Response Surface Method

Study on Synthesis of 2,2-Bis[4-(2-hydroxyethoxy)phenyl]propane in Di-butyl Ether

Synthesis of N-(2-cyanoethyl) diethanolamine

Preparation of diethylamine-d10

Synthesis and Separation of 2-(2, 4-Dinitrophenoxy) Ethanol and Bis (2, 4-Dinitrophenoxy) Ethane

Liquid-liquid Addition Reaction of Ethylene Oxide with Hydrazine Hydrate in Microreactors: Kinetics and Process Optimization

Synthesis of 1,2-Dihexadecyl-sn-glycero-3-phosphoethanolamine

Synthesis and Characterization of (S)-(+)-2-(2-naphthyl)-2-(n-methyl)aminoethanol

Research on the Synthesis of N,N-diethylacrylamide

Alternate Preparation of Norbornene and Dimethanooctahydronaphthalene via Diels–Alder Reaction: Process Simulation and Experimental Verification

Process Intensification of Heterogeneous Dehydrochlorination of Β-Chlorohydrins by Using N-Propanol As Co-Extractant

Optimization of Synthesis Process for Oleoyl-alginate Ester by Response Surface Methodology

Optimization of Technology for Synthesis of Ethylized Glycerol

A Synthesis, Process Optimization, and Mechanism Investigation for the Formation of Polyoxymethylene Dimethyl Ethers

Rational Synthesis of 1,3-Diolein by Enzymatic Esterification.