Abstract:A 20 L hollow-fiber submerged anaerobic membrane bioreactor (SAnMBR) was used to treat real domestic wastewater at 25 °C with hydraulic retention times (HRTs) ranging from 4 to 12 h. The process performance was evaluated by organic removal efficiency, biogas production, sludge yield, and filtration behaviors during one-year's operation. For HRTs ranging between 6 and 12 h, the AnMBR showed good organic removal efficiency with chemical oxygen demand (COD) and biochemical oxygen demand (BOD) removal efficiencies of about 89% and 93%, respectively. The biogas yield was 0.26 L-gas/g-CODfed, with approximately 80% methane content, and the sludge yield was 0.07–0.11 g-VSS/g-CODrem. While at an HRT of 4 h, with the higher wastewater treatment capacity and organic loading rate (OLR), the biogas production was lower (0.17 L-gas/g-CODfed), and the sludge production was higher (0.22 g-VSS/g-CODrem). The organic removal performance (COD 84% and BOD 89%) at HRT of 4 h was acceptable due to the effective separation effect of the membrane filtration process. According to COD balance analysis, the low biogas yield and high sludge yield at HRT of 4 h were due to insufficient biodegradation under an OLR of 2.05 g-COD/L-reactor/d. Theoretical calculations based on Henry's law indicate that the ideal methane content in the biogas should be 82–85% when the operational temperature was 25 °C. To achieve a high flux and sustainable AnMBR operation, the impact of mixed liquor suspended solid (MLSS) and gas sparging velocity (GSV) on the filtration performance was analyzed. The critical flux increased with increase in the GSV from 24.2 to 174.3 m/h, but decreased with increase in the MLSS concentration from 8.2 to 20.2 g/L. Therefore, decreasing fouling rate to 0.8–1.2 kPa/d by efficiently controlling GSV and MLSS, sustainable operation could be achieved at a flux of 0.34 m/d.

The Influence of HRT on Nitrification Performance and Microbial Community Changes of MBR under the Condition of No Sludge Discharge

The Effect of Hydraulic Retention Time on Ammonia and Nitrate Bio-Removal over Nitrite Process

Nitrification and Mass Balance with a Membrane Bioreactor for Municipal Wastewater Treatment

Nitrification and Sludge Characteristics in a Submerged Membrane Bioreactor on Synthetic Inorganic Wastewater

[Impact of Hydraulic Retention Time on Performance of Partial Nitrification Granular Sludge in Continuous Stirred-Tank Reactor].

Aquaculture wastewater treatment using a moving bed biofilm reactor( MBBR)

Nitrification Behavior of Ammonium Nitrogen Under Membrane Bioreactor

Performance and microbial ecology of a nitritation sequencing batch reactor treating high-strength ammonia wastewater

Performance and Microbial Community in Hybrid Anaerobic Baffled Reactor-Constructed Wetland for Nitrobenzene Wastewater

Influence of Hydraulic Retention Time (HRT) upon the Treatment of Wastewater by a Laboratory-Scale Membrane Bioreactor (MBR)

Effect of Increasing C/N Ratio on Performance and Microbial Community Structure in a Membrane Bioreactor with a High Ammonia Load

Nitrogen removal performance and microorganism community of an A/O-MBBR system under extreme hydraulic retention time

Operating characteristics of anaerobic membrane bioreactor for domestic wastewater treatment under ambient temperature

The Influence of Different Operation Conditions on the Treatment of Mariculture Wastewater by the Combined System of Anoxic Filter and Membrane Bioreactor

Effects of HRT and media on nitrogen and phosphorus removal in an integrated biofilm reactor

Nitrification performance and bacterial community dynamics in a membrane bioreactor with elevated ammonia concentration: The combined inhibition effect of salinity, free ammonia and free nitrous acid on nitrification at high ammonia loading rates

Performance and characteristics of a nitritation air-lift reactor under long-term HRT shortening

Effect of sludge retention time on microbial behaviour in a submerged membrane bioreactor

One-year operation of a 20-L submerged anaerobic membrane bioreactor for real domestic wastewater treatment at room temperature: Pursuing the optimal HRT and sustainable flux

Performance of Submerged Membrane Bioreactor for Domestic Wastewater Treatment

Microbial community analysis of membrane bioreactor incorporated with biofilm carriers and activated carbon for nitrification of urine