Abstract:This study aimed to investigate whether separating organics depletion from nitrification increases the overall performance of urine nitrification. Separate organics depletion was facilitated with membrane aerated biofilm reactors (MABRs). The high pH and ammonia concentration in stored urine inhibited nitrification in the first stage and therewith allowed the separation of organics depletion from nitrification. An organics removal of 70 % was achieved at organic loading rates in the influent of 3.7 gCOD d-1 m-2. Organics depletion in a continuous flow stirred tank reactor (CSTR) for organics depletion led to ammonia stripping through diffused aeration of up to 13 %. Using an MABR, diffusion into the lumen amounted for 4 % ammonia loss only. In the MABR, headspace volume and therefore ammonia loss through the headspace was negligible. By aerating the downstream MABR for nitrification with the off-gas of the MABR for organics depletion, 96 % of the ammonia stripped in the first stage could be recovered in the second stage, so that the overall ammonia loss was negligibly low. Nitrification of the organics-depleted urine was studied in MABRs, CSTRs, and sequencing batch reactors in fed batch mode (FBRs), the latter two operated with suspended biomass. The experiments demonstrated that upstream organics depletion can double the nitrification rate. In a laboratory-scale MABR, nitrification rates were recorded of up to 830 mgNL-1 d-1 (3.1 gN m-2 d-1) with ambient air and over 1500 mgNL-1 d-1 (6.7 gN m-2 d-1) with oxygen-enriched air. Experiments with a laboratory-scale MABR showed that increasing operational parameters such as pH, recirculation flow, scouring frequency, and oxygen content increased the nitrification rate. The nitrification in the MABR was robust even at high pH setpoints of 6.9 and was robust against process failures arising from operational mistakes. The hydraulic retention time (HRT) required for nitrification was only 1 to 2 days. With the preceding organics depletion, the HRT for our system requires 2 to 3 days in total, whereas a combined activated sludge system requires 4 to 8 days. The N2O concentration in the off-gas increases with increasing nitrification rates; however, the N2O emission factor was 2.8 % on average and independent of nitrification rates. These results indicate that the MABR technology has a high potential for efficient and robust production of ammonium nitrate from source-separated urine.

Microbial community analysis of membrane bioreactor incorporated with biofilm carriers and activated carbon for nitrification of urine

Biological Nitrogen Removal by A Membrane-Aerated Biofilm Reactor: An Attempt to Treat Urine Wastewater with High Sustainability

Increasing urine nitrification performance with sequential membrane aerated biofilm reactors

Nitrification and Mass Balance with a Membrane Bioreactor for Municipal Wastewater Treatment

Enrichment and Application of Nitrifying Activated Sludge in Membrane Bioreactors.

On-site nutrient recovery and removal from source-separated urine by phosphorus precipitation and short-cut nitrification-denitrification

Performance of pilot-scale membrane aerated biofilm reactors integrated with anoxic nano-biotechnological reactor for domestic wastewater treatment

Microbial composition and nitrogen removal pathways in a novel sequencing batch reactor integrated with semi-fixed biofilm carrier: evidence from a pilot study for low- and high-strength sewage treatment

Mature Landfill Leachate Treatment by the MBBR Inoculated with Biocarriers from a Municipal Wastewater Treatment Plant

Research on the application of heterotrophic nitrification-aerobic denitrification bacteria in membrane bioreactor (MBR)

In-situ enrichment and application of heterotrophic nitrification-aerobic denitrification bacteria in membrane aerated biofilm reactor

A novel integrated bio-reactor of moving bed and constructed wetland (MBCW) for domestic wastewater treatment and its microbial community diversity

Performance and bacterial community analysis of a two-stage A/O-MBBR system with multiple chambers for biological nitrogen removal

Unraveling microbial characteristics of simultaneous nitrification, denitrification and phosphorus removal in a membrane-aerated biofilm reactor

Effects of long-term fertilization with contemporary Danish human urine, composted household waste and sewage sludge on soil nematode abundance and community structure

Evaluation of N-methylpyrrolidone bio-mineralization mechanism and bacterial community evolution under denitrification environment

Bacterial community shift along with the changes in operational conditions in a membrane-aerated biofilm reactor

An Innovative Membrane Bioreactor (MBR) System for Simultaneous Nitrogen and Phosphorus Removal

Nitrogen removal intensification of biofilm through bioaugmentation with Methylobacterium gregans DC-1 during wastewater treatment

Enhanced denitrification of the AO-MBBR system used for expressway service area sewage treatment: A new perspective on decentralized wastewater treatment

Biomass characteristics and simultaneous nitrification-denitrification under long sludge retention time in an integrated reactor treating rural domestic sewage