Experimental study over the effect of the relief duct on the venting of gas explosion in a spherical vessel
Qing-wu ZHANG,Jun-cheng JIANG,Yuan YU,Jin-jun YANG,Yu KE
DOI: https://doi.org/10.13637/j.issn.1009-6094.2015.02.011
2015-01-01
Applied Mechanics and Materials
Abstract:The given paper is aimed at introducing our experimental study over the effect of the relief duct on the ventilation of the gas explosion in a spherical vessel. We have implemented the experiment by using a premixed methane-air mixture([φ(CH4) = 10%]without special instructions) to analyze the effects of the relief duct length,the vessel volume,the ignition position,the gas volume fraction and the membrane rupture pressure on the duct-venting explosion. The results of our experiment show that those parameters have significant effect on the process of the duct-vented explosion. In addition,both the positive pressure and negative pressure in the spherical vessel tend to increase with the increase of the length of the relief duct,whereas in the case of the closed explosion in the isolated spherical vessel,the vessel volume has hardly no effect on the peak pressure of gas explosion,for the gas explosion in the big vessel and the small vessel vented through the same relief duct(the duct length is 6 m and the diameter is 0. 06 m),though the peak pressure in the big vessel can be made as high as 3. 3 times as much as the peak pressure in the small vessel. Therefore,as compared with the closed explosion in the big isolated vessel,for the duct-vented explosion,the rate of pressure rise in the big vessel can be significantly higher because for the duct-vented explosion,compared to central ignition,the peak pressure in the vessel for rear ignition is higher; the relief duct results in that peak pressure in the vessel can be made much higher than that for the simply vented explosion(without relief duct). Therefore,considering the maximum reduced pressure,the duct-vented explosion,or simply the vented explosion,though the peak pressures in the vessel may increase with the increase of membrane rupture pressure,the difference can be gradually made smaller with the increase of the membrane rupture pressure,thus implying that the effect of the duct tends towards the mitigation. What is more,since the presence of the relief duct always tends to reduce the efficiency of the ventilation and increase the severity of the explosion,the effect of the presence of relief duct on venting process should be taken into full account and the compressive strength of the vessel itself should be improved even earlier than when they were at the moment the vessel was under design.