Abstract:The experimental and numerical investigations of the heat transfer of supercritical pressure n-decane flowing through a pipe at various rotational speeds, mass flow rates, heat fluxes, and pressures, are presented. This pipe is 2 mm in diameter, 200 mm in length, with a radius of 0.328 m, and is parallel to the rotating axis. The wall temperature was measured at four positions around the periphery of the pipe at each of the five selected cross section along the pipe's length. Maximum convective heat transfer was observed at the outer edge of the horizontal section, while its corresponding minimum was observed at the inner edge. The heat transfers at the two sides of the channel were observed to be similar. The density and pressure differences between the outer and inner edges increased at increasing rotating speeds. However, the temperature difference between the outer and inner edges decreased with increased rotational speed mainly because of the increase of secondary flows in the section. The section's average convective heat transfer coefficient increased with an increase in the rotational speed, and its value at 1000 rpm was approximately twice than that at static conditions. The phenomenon of oscillation was observed near the exit of the horizontal section, and was caused by the flow and considerable property changes near the pseudo critical temperature. A computational fluid dynamics (CFD) model was developed using the real gas thermal properties and was coupled with the heat transferred owing to fuel flow. The predicted fuel and wall temperatures were in good agreement with the experimental data. A new local Nusselt number correlation of the heat transfer of n-decane in a rotating horizontal section was proposed.

Numerical Study on Turbulent Heat Transfer of Supercritical n-Decane in a Square Regenerative Cooling Channel

Flow Dynamics in Transient Heat Transfer of N-Decane at Supercritical Pressure

Numerical Study on Turbulent Convective Heat Transfer with n-heptane Under Supercritical Pressures

A Numerical Study of Supercritical Forced Convective Heat Transfer of N-Heptane Inside A Horizontal Miniature Tube

Numerical Investigation on Heat Transfer Characteristics of Supercritical N-Decane in a Regenerative Cooling Channel with Inverted Pyramid Trusses

Supercritical Heat Transfer of Cryogenic-Propellant Methane in Rectangular Engine Cooling Channels

Numerical Investigation of Convective Heat Transfer of Supercritical Hydrocarbon Fuel in a Tube Filled With Porous Media

Experimental Investigation of Convective Heat Transfer of Hydrocarbon Fuels at Supercritical Pressures Within Rotating Centrifugal Channel

Supercritical-Pressure Heat Transfer, Pyrolytic Reactions, and Surface Coking of N-Decane in Helical Tubes

Study of Heat Transfer of Cryogenic Methane under Supercritical Pressure with Consideration of Thermal Conduction in Engine Cooling Channel Walls

Numerical Model Development and Validation for Hydrocarbon Fuel Supercritical Heat Transfer with Endothermic Pyrolysis

Experimental Investigation of the Flow and Heat Transfer Instabilities in N-Decane at Supercritical Pressures in a Vertical Tube

Numerical Modeling of Turbulent Heat Transfer of a Nanofluid at Supercritical Pressure

Enhanced Heat Transfer of Supercritical N-Decane in Cooling Channels with Triangular Ribs for Regenerative Cooling

Three-dimensional Numerical Study of Supercritical Pressure Effect on Heat Transfer of Cryogenic Methane

Experimental investigation of convective heat transfer of supercritical pressure hydrocarbon fuel in a horizontal section of a rotating U-duct

Numerical Study of Conjugate Heat Transfer of Cryogenic Methane in Rectangular Engine Cooling Channels at Supercritical Pressures

Flow and Heat Transfer Characteristics of Supercritical N-Decane in Adjacent Cooling Channels with Opposite Flow Directions

Experiment on Flow and Convective Heat Transfer Instability of N-Decane in a Vertical Tube at Supercritical Pressures

Boundary Effects on Flow Oscillations in Transient Heat Transfer of N-Decane at Supercritical Pressure

Numerical Analysis of Convective Heat Transfer Characteristics of Supercritical Hydrocarbon Fuel in Cooling Panel with Local Flow Blockage Structure