Abstract:The aerodynamic performance of a reduced-scale coaxial rigid rotor system in hover and steady forward flights was experimentally investigated to gain insights into the effect of interference between upper and lower rotors and the influences of the advance ratio, shaft tilt angle and lift offset. The rotor system featured by 2 m-diameter, four-bladed upper and lower hingeless rotors and was installed in a coaxial rotor test rig. Experiments were conducted in the Φ3.2 m wind tunnel at China Aerodynamics Research and Development Center (CARDC). The rotor system was tested in hover states at collective pitches ranging from 0° to 13° and it was also tested in forward flights at advance ratios up to 0.6, with specific focus on the shaft tilt angle and lift offset sweeps. To ensure that the coaxial rotor was operating in a similar manner to that of the real flight, the torque difference was trimmed to zero in hover flight, whilst the constant lift coefficient was maintained in forward flight. An isolated single-rotor configuration test was also conducted with the same pitch angle setting in the coaxial rotor. The hover test results demonstrate that the figure of merit (FM) value of the lower rotor is lower than that of the upper rotor, and both are lower than that of the isolated single rotor. Moreover, the coaxial rotor configuration can contribute to better hover efficiency under the same blade loading coefficient (CT/σ). In forward flight, the effective lift-to-drag (L/De) ratio of the coaxial rigid rotor does not monotonously change as the advance ratio increases. Increases in the required power and drag in the case with a high advance ratio of 0.6 leads to the decreasing L/De ratio of the rotor. Meanwhile, the L/De ratio of the rotor is relatively high when the rotor shaft is tilted backward. The increasing lift offset tends to result in reduced required rotor power and an increase in the rotor drag. When the effect of the reduced rotor power is greater than that of the increased rotor drag, the L/De ratio increases as the lift offset increases. The L/De ratio can benefit significantly from lift offset at a high advance ratio, but it is much less influenced by lift offset at a low advance ratio. The forward performance efficiency of the upper rotor is poorer than that of the lower rotor, which is significantly different from the case in the hover flight.

Investigation of Bioinspired Flow for a Nano Coaxial Rotor in Hover

Bio-inspired Nano Rotor Investigation Based on UVLM

Propulsion Performance Investigation of Bio-Inspired Nano Rotor Base on Fluid–structure Interaction

Experimental and Computational Investigations of Flexible Membrane Nano Rotors in Hover

Computational Investigation of Blade–Vortex Interaction of Coaxial Rotors for Evtol Vehicles

Numerical Simulation and Aerodynamic Investigation of the Intermeshing Rotor in Hover

Computational Study on the Aerodynamics of a Long-Shrouded Contra-Rotating Rotor in Hover

Numerical Investigation of Aerodynamic Interactions for the Coaxial Rotor System in Low-Speed Forward Flight

DESIGN, FABRICATION AND HOVERING PERFORMANCE STUDY OF NANO COAXIAL ROTOR

A High-Resolution Numerical Investigation of Unsteady Wake Vortices for Coaxial Rotors in Hover

Experimental and Computational Evaluation of Small Microcoaxial Rotor in Hover

An rVPM-Based Aerodynamic Hybrid Optimization Method for Coaxial Rotor with Differentiated Upper and Lower Blades in Both Hover and High-Speed Cruising States

Wind Tunnel Studies on Hover and Forward Flight Performances of a Coaxial Rigid Rotor

Experimental and Computational Analysis of Microscale Shrouded Coaxial Rotor in Hover

Numerical simulation of interaction unsteady flows around co-axial rotors in hover

Computational Investigation of Noise Interaction for a Nano Counter-Rotating Rotor in a Static Condition

Numerical Simulation of Unsteady Flow Past Autorotating Rotor in Gyroplane Level Flight

A New Way of Simulating the Flow Field of a Lifting Rotor in Hover

Investigation on Aerodynamic Characteristics of Bionic Membrane Nano Rotor

Coaxial rotor helicopter in hover based on unstructured dynamic overset grids

Evaluation of Nano-Scale Rotors and Motors at Static Condition