Abstract:The aerodynamic performance of a reduced-scale coaxial rigid rotor system in hover and steady forward flights was experimentally investigated to gain insights into the effect of interference between upper and lower rotors and the influences of the advance ratio, shaft tilt angle and lift offset. The rotor system featured by 2 m-diameter, four-bladed upper and lower hingeless rotors and was installed in a coaxial rotor test rig. Experiments were conducted in the Φ3.2 m wind tunnel at China Aerodynamics Research and Development Center (CARDC). The rotor system was tested in hover states at collective pitches ranging from 0° to 13° and it was also tested in forward flights at advance ratios up to 0.6, with specific focus on the shaft tilt angle and lift offset sweeps. To ensure that the coaxial rotor was operating in a similar manner to that of the real flight, the torque difference was trimmed to zero in hover flight, whilst the constant lift coefficient was maintained in forward flight. An isolated single-rotor configuration test was also conducted with the same pitch angle setting in the coaxial rotor. The hover test results demonstrate that the figure of merit (FM) value of the lower rotor is lower than that of the upper rotor, and both are lower than that of the isolated single rotor. Moreover, the coaxial rotor configuration can contribute to better hover efficiency under the same blade loading coefficient (CT/σ). In forward flight, the effective lift-to-drag (L/De) ratio of the coaxial rigid rotor does not monotonously change as the advance ratio increases. Increases in the required power and drag in the case with a high advance ratio of 0.6 leads to the decreasing L/De ratio of the rotor. Meanwhile, the L/De ratio of the rotor is relatively high when the rotor shaft is tilted backward. The increasing lift offset tends to result in reduced required rotor power and an increase in the rotor drag. When the effect of the reduced rotor power is greater than that of the increased rotor drag, the L/De ratio increases as the lift offset increases. The L/De ratio can benefit significantly from lift offset at a high advance ratio, but it is much less influenced by lift offset at a low advance ratio. The forward performance efficiency of the upper rotor is poorer than that of the lower rotor, which is significantly different from the case in the hover flight.

Research on the Influence of Key Parameters on the Aerodynamic Characteristics of Shaftless Ducted Rotors

Airfoil Parameterization Evaluation Based on a Modified PARASEC Method for a H-Darrious Rotor

Experimental Study of Two-Stage Savonius Rotors with Different Gap Ratios and Phase Shift Angles

The Overall Design of Variable Diameter Ducted Fan in the Aircraft

Study On The Mechanism Of The Variable-Speed Rotor Affecting Rotor Aerodynamic Performance

Numerical study on aerodynamic performance of a ducted tail rotor in hover and sideward flight

The effect of tip rake distribution on the hydrodynamic performance of shaftless rim-driven contra-rotating thruster

Numerical Investigation of Influence of Rotor-Rotor Gap on Performances of Contra-Rotating Axial Flow Pump

A Study on the Effect of Toroidal Propeller Parameters on Efficiency and Thrust

Investigation of Helicopter Rotor Aerodynamic Characteristics in Axial Descent with Viscous Vortex Particle Method

Multidisciplinary Aerodynamic Design of a Rotor Blade for an Optimum Rotor Speed Helicopter

Experimental Investigation on Hover Performance of a Ducted Coaxial-Rotor UAV

Active Subspace-Based Performance Analysis of Supersonic Through-Flow Fan Rotor

Systematic investigation of effect of rotor solidity on vertical-axis wind turbines: Power performance and aerodynamics analysis

Aerodynamic Optimization Design of Duct Body Structure for Coaxial Rotor Unmanned Aerial Vehicles

Comparative Investigation on Improved Aerodynamic and Acoustic Performance of Abnormal Rotors by Bionic Edge Design and Rational Material Selection

Investigation on drag reduction on rotating blade surfaces with microtextures

Numerical Analysis of the Hydrodynamic Performance Impact of Novel Appendage on Rim-driven Thruster

Numerical Research On Effects Of Shroud Contraction On Tip Leakage Flow And Overall Performance Of Axial Compressors

Wind Tunnel Studies on Hover and Forward Flight Performances of a Coaxial Rigid Rotor