Abstract:In this study, the preferential concentration and clustering of inertial particles in fully developed turbulent square duct flows are studied using large eddy simulations combined with Lagrangian approach, where the Reynolds number is equal to Reτ = 600 (based on the mean friction velocity and duct full height), and the particle Stokes number ranges from 0.0007 to 1.16. The results obtained for duct flows are compared with those for channel flows under the same working conditions. Then, the effect of the secondary flow on the particle concentration in duct flows is investigated. The equation of particle motion is governed by the drag force, lift force, added mass force, pressure gradient force, and gravity. The inter-phase interaction that was considered includes one-way and two-way coupling. The simulations of a single phase are verified and in good agreement with the available literature data. For the discrete phase, particles in the duct flow are found to be more dispersed in the vertical direction compared with the channel flow. In near-wall regions, a small fraction of particles tends to accumulate in duct corners, forming stable particle streaks under the effect of the secondary flow. Meanwhile, most particles are likely to reside preferentially in the low-speed flow regions and form elongated particle streaks steadily in the middle region of duct or channel floors. The Voronoi diagram analysis shows that the near-wall secondary flows in the square duct could cause particle clusters to transfer from regions of high to low concentration, and this trend increases with particle size. In addition, two-way coupling is found to enhance the near-wall particle accumulation and to promote particles to form more elongated streaks than one-way coupling. Finally, the mechanism responsible for the particle preferential concentration in turbulent square duct flows is determined.

On the role of secondary motions in turbulent square duct flow

Turbulence and secondary motions in square duct flow

Effects of the Computational Domain on the Secondary Flow in Turbulent Plane Couette Flow

Direct numerical simulation of turbulent channel flow with spanwise rotation

Turbulent Statistics and Flow Structures in Spanwise-Rotating Turbulent Plane Couette Flows

Direct numerical simulation of developed compressible flow in square ducts

Coherent structures and secondary flow in turbulent square duct

DNS of transitional and turbulent flows in rectangular ducts

Direct numerical simulation of forced thermal convection in square ducts up to $Re_τ\approx 2000$

Effects of Finite-Size Heavy Particles on the Turbulent Flows in a Square Duct

Rearrangement of secondary flow over spanwise heterogeneous roughness

Large Scale Structures Of Turbulent Shear Flow Via Dns

Direct Numerical Simulation of Turbulent Flow in A Rotating Square Duct

Direct Numerical Simulation for Laminarization of Turbulent Forced Gas Flows in Circular Tubes with Strong Heating

Numerical and experimental study of mechanisms responsible for turbulent secondary flows in boundary layer flows over spanwise heterogeneous roughness

Effect of turbulence-driven secondary flow on particle preferential concentration and clustering in turbulent square duct flows

Direct Numerical Simulation Of Turbulent Heat Transfer In An Axially Rotating Pipe Flow - Reynolds Shear Stress And Scalar Flux Budgets

Direct numerical simulation of supersonic pipe flow at moderate Reynolds number

Numerical investigation on spatial development of the secondary flow in a supersonic turbulent square duct

Wall pressure and secondary-flow origination in a square duct

Direct Numerical Simulation of Coherent Structure in Turbulent Open-Channel Flows with Heat Transfer