Abstract:With the rapid development of wearable intelligent devices, low-cost wearable strain sensors with high sensitivity and low detection limit are urgently demanded. Meanwhile, sensing stability of sensor in wet or corrosive environments should also be considered in practical applications. Here, superhydrophobic microcracked conductive paper-based strain sensor was fabricated by coating conductive Ti3C2Tx MXene on printing paper via dip-coating process and followed by depositing superhydrophobic candle soot layer on its surface. Owing to the ultrasensitive microcrack structure in the conductive coating layer induced by the mismatch of elastic modulus and thermal expansion coefficient between conductive coating layer and paper substrate during the drying process, the prepared paper-based strain sensor exhibited a high sensitivity (gauge factor, GF = 17.4) in the strain range of 0-0.6%, ultralow detection limit (0.1% strain) and good fatigue resistance over 1000 cycles towards bending deformation. Interestingly, it was also applicable for torsion deformation detection, showing excellent torsion angle dependent, repeatable and stable sensing performances. Meanwhile, it displayed brilliant waterproof, self-cleaning and corrosion-resistant properties due to the existence of micro/nano-structured and the low surface energy candle soot layer. As a result, the prepared paper-based strain sensor can effectively monitor a series of large-scale and small-scale human motions even under water environment, showing the great promising in practical harsh outdoor environments. Importantly, it also demonstrated good applicability for spatial strain distribution detection of skin upon body movement when assembled into electronic-skin (E-skin). This study will provide great guidance for the design of next generation wearable strain sensor.

Superhydrophobic, Stretchable and Conductive Elastomeric Strip for Human Motion Detection

Facile and Economical Fabrication of Superhydrophobic Flexible Resistive Strain Sensors for Human Motion Detection

A Superhydrophobic Wearable Rubber Band with a Synergistic Dual Conductive Layer for Monitoring Human Motions

High‐Performance, Superhydrophobic, and Wearable Strain Sensor for Amphibious Human Motion Detection

A flexible strain sensor based on CNTs/PDMS microspheres for human motion detection

Fabrication of superhydrophobic conductive film at air/water interface for flexible and wearable sensors

Superhydrophobic conductive rubber band with synergistic dual conductive layer for wide-range sensitive strain sensor

Strain Sensor with High Sensitivity and Large Response Range Based on Self-Assembled Elastic-Sliding Conductive Networks

Stretchable and Sensitive Strain Sensors Based on CB/MWCNTs–TPU for Human Motion Capture and Health Monitoring

Flexible Superamphiphobic Film with a 3D Conductive Network for Wearable Strain Sensors in Humid Conditions

Highly stretchable and sensitive flexible resistive strain sensor based on waterborne polyurethane polymer for wearable electronics

Stretchable Strain Sensor for Human Motion Monitoring Based on an Intertwined-Coil Configuration

A highly stretchable, super-hydrophobic strain sensor based on polydopamine and graphene reinforced nanofiber composite for human motion monitoring

Extremely stretchable strain sensors with ultra-high sensitivity based on carbon nanotubes and graphene for human motion detection

Highly Sensitive and Stretchable MXene/CNTs/TPU Composite Strain Sensor with Bilayer Conductive Structure for Human Motion Detection.

Ultrasensitive strain sensor based on superhydrophobic microcracked conductive Ti3C2Tx MXene/paper for human-motion monitoring and E-skin

Ultra-stretchable, super-hydrophobic and high-conductive composite for wearable strain sensors with high sensitivity

Multifunctional flexible strain sensor based on excellent sensing performance PDMS-MXene@CNT/TPU nanofiber membrane with hydrophobic and photothermal conversion performance

Highly sensitive and stretchable strain sensors based on serpentine-shaped composite films for flexible electronic skin applications

Superstretchable and Linear-Response Strain Sensors With Carbon Nanotubes Ultrasonically Assembled on Silicone Rubber Film

A Highly Stretchable and Sensitive Strain Sensor Based on Dopamine Modified Electrospun SEBS Fibers and MWCNTs with Carboxylation