Abstract:Under part-load conditions, a Francis turbine often suffers from very severe low-frequency and large-amplitude pressure fluctuation, which is caused by the unsteady motion of vortices (known as “vortex ropes”) in the draft tube. This paper first reports our numerical investigation of relevant complex flow phenomena in the entire draft tube, based on the Reynolds-averaged Navier–Stokes (RANS) equations. We then focus on the physical mechanisms underlying these complex and somewhat chaotic flow phenomena of the draft-tube flow under a part-load condition. The flow stability and robustness are our special concern, since they determine what kind of control methodology will be effective for eliminating or alleviating those adverse phenomena. Our main findings about the flow behavior in the three segments of the draft tube, i.e., the cone inlet, the elbow segment, and the outlet segment with three exits, are as follows. (1) In the cone segment, we reconfirmed a previous finding of our research group based on the turbine’s whole-flow RANS computation that the harmful vortex rope is an inevitable consequence of the global instability of the swirling flow. We further identified that this instability is caused crucially by the reversed axial flow at the inlet of the draft tube. (2) In the elbow segment, we found a reversed flow continued from the inlet cone, which evolves to slow and chaotic motion. There is also a fast forward stream driven by a localized favorable axial pressure gradient, which carries the whole mass flux downstream. The forward stream and reversed flow coexist side-by-side in the elbow, with a complex and unstable shear layer in between. (3) In the outlet segment with three exits, the forward stream always goes through a fixed exit, leaving the other two exits with a chaotic and low-speed fluid motion. Based on these findings, we propose a few control principles to suppress the reversed flow and to eliminate the harmful helical vortex ropes. Of the methods we tested numerically, a simple jet injection in the inlet is proven successful.

Investigation on Mutual Traveling Influences Between the Draft Tube and Upstream Components of a Francis Turbine Unit

Numerical Predictions and Stability Analysis of Cavitating Draft Tube Vortices at High Head in a Model Francis Turbine

Characteristics and Control of the Draft-Tube Flow in Part-Load Francis Turbine

Experimental Investigation on the Characteristics of Hydrodynamic Stabilities in Francis Hydroturbine Models

Analysis and Control of Part-Load Unsteady Flow in Francis Turbine’s Draft Tube

Internal flow characteristics in the draft tube of a Francis turbine under different working conditions

Study on flow instability and countermeasure in a draft tube with swirling flow

The Influence of Hydraulic Characteristics on Structural Performance in a Pump-Turbine under No-Load Conditions

Investigation of Pressure Fluctuation and Pulsating Hydraulic Axial Thrust in Francis Turbines

Study on the method of reducing the pressure fluctuation of hydraulic turbine by optimizing the draft tube pressure distribution

Transient Flow Dynamics Analysis of a Large Prototype Francis Turbine at Different Loads

Comparison of Pressure Pulsation Characteristics of Francis Turbine with Different Draft Tube Arrangement Direction

Numerical Simulation of Pressure Vibrations in a Francis Turbine Draft Tube with Air Admission

Experimental investigation and numerical simulation of flow in the draft tube elbow of a Francis turbine over its entire operating range

Comparisons of Vortical Flow and Cavitation Inside a Francis Turbine with Different Draft Tubes

Pressure Oscillation Suppression by Air Admission in a Francis Turbine Draft Tube

Investigation of the Internal Flow in a Francis Turbine for Comparing the Flow Noise of Different Operation Conditions

The Influence of Structure Optimization on Vortex Suppression and Energy Dissipation in the Draft Tube of Francis Turbine

Effectiveness of Air Admission Through Short Pipes in Reducing Pressure Fluctuation of Propeller Hydro-turbine Flow Channel

Effects of Head and Discharge on Internal Flow Characteristics of a High-Quality Installed 1 GW Francis Turbine

Experimental investigation on the characteristics and alleviation of the upper part load pressure fluctuation in a Francis turbine