Abstract:Compositing amorphous carbon (a-C) film with fluid lubricant could successfully improve the friction properties and prolong the service life and reliability of protected components. However, the inevitable existence of unsaturated molecules in base oil, especially its potential effect on the friction behavior and related mechanism are still not fully understood. In this paper, the friction behavior of amorphous carbon (a-C) composited with unsaturated hydrocarbon lubricant, C5H10 as one of linear alpha olefins (AO), was explored by reactive molecular dynamics simulation, and the role of C5H10 content on friction property and interfacial structure was mainly analyzed. Results revealed that at the fixed contact pressure, the unsaturated C5H10 bound with a-C in the form of weak intermolecular interactions rather than chemical bonding and there was also no C5H10 dissociation observed; the friction coefficient was strongly dependent on the small unsaturated hydrocarbon, which decreased obviously with C5H10 content. In particular, compared to the dry condition, the existence of C5H10 molecules at the friction interface could significantly reduce the friction coefficient by 99.2% maximally. By the systematical analysis of interfacial hybridization structure and AO mobility, it indicated that the synergistic mechanism for the low friction originated from the self-passivation of a-C surface and AO hydrodynamic lubrication. Our results not only disclose the effect of unsaturated hydrocarbon molecules in bas oil on friction behavior and define the underlying lubrication mechanism, but also suggest a strategy for the design of both fluid lubricant and friction interface to realize the long-lifetime application.

Molecular Dynamics Simulation Of Different Configurations Of Pao Molecules In Shear Iron Plates

Effects of molecular structures of poly α-olefin mixture on nano-scale thin film lubrication

The effect of the number of branched hydrocarbon molecules on boundary lubrication of ZnO nanofluids by using molecular dynamics simulation

Effect of the Combination of Antioxidant and Dispersant in Traction Oils on Their Interactions and Lubricating Property

Experimental Investigation of Lubrication Failure of Polyalphaolefin Oil Film at High Slide/Roll Ratios

Influence of Base Oil Molecular Structure on the Tribological Performance of Diesel Engine Cylinder Liner and Piston Ring

Friction and Wear Protection Performance of Synthetic Siloxane Lubricants

Nonequilibrium molecular dynamics investigation on friction behavior of organic friction modifiers under dynamic load

Tribo‐Induced Structural Transformation and Lubricant Dissociation at Amorphous Carbon–Alpha Olefin Interface

Study on the Sliding Tribological Behavior of Oleic Acid-Modified MoS 2 under Boundary Lubrication

Study on the Sliding Tribological Behavior of Oleic Acid-Modified MoS2 under Boundary Lubrication.

Role of Unsaturated Hydrocarbon Lubricant on the Friction Behavior of Amorphous Carbon Films from Reactive Molecular Dynamics Study

Molecular Dynamics Simulation of the Structure and Friction Properties of Thin Film Lubrication

Effects of Surface Nanostructure on Boundary Lubrication Using Molecular Dynamics

The tribological performance evaluation of steel-steel contact surface lubricated by polyalphaolefins containing surfactant-modified hybrid MoS2/h-BN nano-additives

Molecular Dynamics Investigation Of Graphene Nanoplate Diffusion Behavior In Poly-Alpha-Olefin Lubricating Oil

Boundary slip and lubrication mechanisms of organic friction modifiers with effect of surface moisture

Tribological Behaviors of Several Polymer–polymer Sliding Combinations under Dry Friction and Oil-Lubricated Conditions

Synergistic Lubrication of Diamond-Like Carbon and Poly-Α-Olefin Oil: Coupled Dependence on Oil Viscosity and Applied Load

Preparation of Nanofluid of Lanthanum Borate Nanosheets and Investigation of Its Tribological Properties and Tribomechanisms in Different Base Oils

Study on Lubrication Characteristics of C4-Alkane and Nanoparticle during Boundary Friction by Molecular Dynamics Simulation