Abstract:In an effort to understand what occurred at the mineral-solution interface during the arsenopyrite (Apy) oxidation process, one arsenopyrite block was cut into 15 cubes (side length of approximately 2.5 mm), which were reacted with sulphuric acid at 100-300 degrees C in a reaction autoclave sealed by a metal screw like vessel. The pH levels of the acid solutions are 0, 1, and 3. After the reaction, various techniques were used to investigate both the chemical, morphological and mineralogical changes. Among these techniques, inductively coupled plasma atomic emission spectroscopy (ICP-AES) was used to analyze the remaining solutions after the reaction. Scanning electron microscopy (SEM) and Transmission Electron Microscopy (TEM) were used for the morphological analysis and mineral analysis of the products. The products at the residual solid surface were examined using X-ray photoelectron spectroscopy (XPS), electron probe microanalysis (EPMA), the X-ray powder diffractometry (XRD) and micro-XRD test. The ICP-AES results indicate that a large amount of As moves into solution and that the total level of As ions in the solution significantly increased as the temperature and acid concentration increased. The secondary electron image (SEI) coupled with the backscattered electron image (BEI) of the morphology shows that the dissolution of arsenopyrite starts from the edges of the cube and fracture. Then, the action interface gradually migrates into the inside of the mineral cube. The XPS narrow scan of the residual solid surface indicates that Fe3+, S8, SO32-, SO42-, As3+, As5+ and a small amount of As1+ are generated at the surface, among which As3+ dominates. The XPS profile analysis of As 2p3/2 indicates that with an increase in the erosion depth from inner to the surface, the concentration of oxidized As increases; the reaction prompts arsenopyrite to oxidize and generates the oxidized state of As. And multiple-layer concentric banded structure may be reached according to the disappearance of every oxidized state of As. Due to the transfer of a large amount of oxidized As to the hydrothermal fluid from the As-containing minerals and rocks, the oxidation of arsenopyrite means that As would be released into hydrothermal fluid as well as to the superficial water and groundwater circulation. (C) 2016 Elsevier Ltd. All rights reserved.

Formation Process of the Passivating Products from Arsenopyrite Bioleaching by Acidithiobacillus Ferrooxidans in 9K Culture Medium

Electrochemical behaviour of the oxidative dissolution of arsenopyrite catalysed by Ag+ in 9K culture medium

Effects of Fe and cost-effective media composition on arsenopyrite bioleaching by Sulfobacillus thermosulfidooxidans

Novel insights into the kinetics and mechanism of arsenopyrite bio-dissolution enhanced by pyrite

Arsenopyrite Bio-Oxidization Behavior in Bioleaching Process: Evidence From Laser Microscopy, SEM-EDS, and XPS

Passivation of metal sulfides by a marine bacterium for acid mine drainage control

(Bio)dissolution of arsenopyrite coupled with multiple proportions of pyrite: Emphasis on the mobilization and existential state of arsenic

A Comparison of Bioleaching of Chalcopyrite Using Pure Culture or a Mixed Culture

Transformation of Arsenic During Realgar Tailings Stabilization Using Ferrous Sulfate in a Pilot-Scale Treatment.

Electrochemical studies on dissolution and passivation behavior of low temperature bioleaching of chalcopyrite by Acidithiobacillus ferrivorans YL15

Collaborative effects of Acidithiobacillus ferrooxidans and ferrous ions on the oxidation of chalcopyrite

Secondary Minerals on Arsenopyrite Oxidized by Acidithiobacillus ferrooxidans

Biofilm formation and development during the pyrite bioleaching of moderately thermophilic microorganisms

Sulfide Minerals Bio-Oxidation of a Low-Grade Refractory Gold Ore

Hydrothermal Alteration of Arsenopyrite by Acidic Solutions

Acidithiobacillus ferrooxidans and mixed Acidophilic microbiota oxidation to remove sulphur impurity from iron concentrate

Fe/S oxidation-coupled arsenic speciation transformation mediated by AMD enrichment culture under different pH conditions

Bioleaching of Chalcopyrite by Acidithiobacillus Ferrooxidans

A Novel Surface Passivation Method of Pyrite within Rocks in Underwater Environments to Mitigate Acid Mine Drainage at Its Source

Sulfur Transformation in Microbially Mediated Pyrite Oxidation by Acidithiobacillus Ferrooxidans: Insights from X-ray Photoelectron Spectroscopy-Based Quantitative Depth Profiling

Linked variations of bioleaching performance, extracellular polymeric substances (EPS) and passivation layer in the uranium bacterial-leaching system