Abstract:The selective hydrogenation of acetylene has been studied over AgPd and CuPd catalysts. Controlled surface reactions were used to synthesize these bimetallic nanoparticles on both TiO2 and SiO2 supports. Chemisorption measurements of the bimetallic catalysts indicate that Pd prefers to be on the nanoparticle surface with a Cu parent catalyst, while Pd prefers to be subsurface with a Ag parent catalyst. From energy-dispersive X-ray spectroscopy analysis, the composition of the nanoparticles is determined to be more uniform on the SiO2 support compared to that on the TiO2 support. X-ray absorption spectroscopy results indicate that, after reduction, the CuPd bimetallic catalysts have some Pd–Pd bonds, but the average number of Pd–Pd bonds decreases after reaction. Infrared spectra of the adsorbed CO show that an increased fraction of isolated Pd species are present on the bimetallic catalysts compared to those on the monometallic catalysts. Adsorption of acetylene and ethylene, however, indicates adsorbed surface species that require contiguous Pd ensembles. These results suggest that the surface structure of the catalyst is highly dynamic and influenced by the gas environment, as well as the support. The catalysts are active for the selective hydrogenation of acetylene in an ethylene-rich environment under mild conditions. Over all catalysts, the ethylene selectivity is greater than 92%; however, improved selectivity is observed over the bimetallic catalysts compared to that over the monometallic Pd catalysts. An ethylene selectivity of 100% is observed over the CuPd0.08/TiO2 catalyst. The highest acetylene conversion rate per gram of Pd is observed over the CuPd0.02/TiO2 catalyst, while the highest turnover frequency is found over the AgPd0.64/TiO2 catalyst. The bimetallic SiO2-supported catalysts have lower rates than Pd/SiO2 but still show improved selectivity. The combined characterization measurements and reaction kinetics studies indicate that the performance improvements of the bimetallic catalysts may be attributed to both electronic and geometric modifications of Pd by the parent Cu or Ag metal.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acscatal.0c01536?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acscatal.0c01536</a>.UV–vis spectra during catalyst synthesis, FTIR spectra of TiO2 and SiO2 supports after reaction mixture adsorption, XANES and EXAFS spectra, and reaction time on stream data for acetylene conversion (<a class="ext-link" href="/doi/suppl/10.1021/acscatal.0c01536/suppl_file/cs0c01536_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Tailoring Electronic Properties and Kinetics Behaviors of Pd/N‐CNTs Catalysts for Selective Hydrogenation of Acetylene

Optimizing Alkyne Hydrogenation Performance of Pd on Carbon in Situ Decorated with Oxygen-Deficient TiO2 by Integrating the Reaction and Diffusion

Enhancing Both Selectivity and Coking-Resistance of a Single-Atom Pd 1 /C 3 N 4 Catalyst for Acetylene Hydrogenation

Enhancing both selectivity and coking-resistance of a single-atom Pd1/C3N4 catalyst for acetylene hydrogenation

The Influence of Pd Particles Distribution Position on Pd/CNTs Catalyst for Acetylene Selective Hydrogenation

Adsorbate-Induced Structural Evolution of Pd Catalyst for Selective Hydrogenation of Acetylene

Carbon-confined Cu-Pd alloy nanoparticles as high-performance catalysts for acetylene selective hydrogenation

Sharp Increase in Catalytic Selectivity in Acetylene Semihydrogenation on Pd Achieved by a Machine Learning Simulation-Guided Experiment

Tuning electronic structure of palladium from wheat flour-derived N-doped mesoporous carbon for efficient selective hydrogenation of acetylene

50 Ppm of Pd Dispersed on Ni(OH)2 Nanosheets Catalyzing Semi-Hydrogenation of Acetylene with High Activity and Selectivity

AgPd and CuPd Catalysts for Selective Hydrogenation of Acetylene

Pd Single‐Atom Catalysts on Nitrogen‐Doped Graphene for the Highly Selective Photothermal Hydrogenation of Acetylene to Ethylene

Fine tuning the dynamic PdC x formation for enhanced acetylene semi-hydrogenation: The role of gas environment and ZnO addition

Catalytic Properties of Supported Pd/Tio2 and Pd-Ag/Tio2 Catalysts for Selective Hydrogenation of Acetylene

Atomically Dispersed Pd On Nanodiamond/Graphene Hybrid For Selective Hydrogenation Of Acetylene

Same Size, Same Support, Same Spectator? Selective Acetylene Hydrogenation on supported Pd Nanoparticles

Pyridinic nitrogen dominated doping on Pd/carbon catalysts for enhanced hydrogenation performance

Controllable Deposition of Bi Onto Pd for Selective Hydrogenation of Acetylene.

PdZn Intermetallic Nanostructure with Pd–Zn–Pd Ensembles for Highly Active and Chemoselective Semi-Hydrogenation of Acetylene

Dual effect of TiO2 vacancy on Pd catalyst in acetylene hydrogenation: boosting performance and capturing reaction heat

Selective hydrogenation of acetylene on carbon-encapsulated Ni-Co-Cu trimetallic nanoparticles: Synergizing electronic effects and spatial confinement