Abstract:The selective hydrogenation of acetylene has been studied over AgPd and CuPd catalysts. Controlled surface reactions were used to synthesize these bimetallic nanoparticles on both TiO2 and SiO2 supports. Chemisorption measurements of the bimetallic catalysts indicate that Pd prefers to be on the nanoparticle surface with a Cu parent catalyst, while Pd prefers to be subsurface with a Ag parent catalyst. From energy-dispersive X-ray spectroscopy analysis, the composition of the nanoparticles is determined to be more uniform on the SiO2 support compared to that on the TiO2 support. X-ray absorption spectroscopy results indicate that, after reduction, the CuPd bimetallic catalysts have some Pd–Pd bonds, but the average number of Pd–Pd bonds decreases after reaction. Infrared spectra of the adsorbed CO show that an increased fraction of isolated Pd species are present on the bimetallic catalysts compared to those on the monometallic catalysts. Adsorption of acetylene and ethylene, however, indicates adsorbed surface species that require contiguous Pd ensembles. These results suggest that the surface structure of the catalyst is highly dynamic and influenced by the gas environment, as well as the support. The catalysts are active for the selective hydrogenation of acetylene in an ethylene-rich environment under mild conditions. Over all catalysts, the ethylene selectivity is greater than 92%; however, improved selectivity is observed over the bimetallic catalysts compared to that over the monometallic Pd catalysts. An ethylene selectivity of 100% is observed over the CuPd0.08/TiO2 catalyst. The highest acetylene conversion rate per gram of Pd is observed over the CuPd0.02/TiO2 catalyst, while the highest turnover frequency is found over the AgPd0.64/TiO2 catalyst. The bimetallic SiO2-supported catalysts have lower rates than Pd/SiO2 but still show improved selectivity. The combined characterization measurements and reaction kinetics studies indicate that the performance improvements of the bimetallic catalysts may be attributed to both electronic and geometric modifications of Pd by the parent Cu or Ag metal.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acscatal.0c01536?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acscatal.0c01536</a>.UV–vis spectra during catalyst synthesis, FTIR spectra of TiO2 and SiO2 supports after reaction mixture adsorption, XANES and EXAFS spectra, and reaction time on stream data for acetylene conversion (<a class="ext-link" href="/doi/suppl/10.1021/acscatal.0c01536/suppl_file/cs0c01536_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

50 Ppm of Pd Dispersed on Ni(OH)2 Nanosheets Catalyzing Semi-Hydrogenation of Acetylene with High Activity and Selectivity

Highly Active Isolated Single-Atom Pd Catalyst Supported on Layered MgO for Semihydrogenation of Acetylene

Atomically Dispersed Pd On Nanodiamond/Graphene Hybrid For Selective Hydrogenation Of Acetylene

Mesoporous Nitrogen‐Doped Carbon‐Nanosphere‐Supported Isolated Single‐Atom Pd Catalyst for Highly Efficient Semihydrogenation of Acetylene

Enhancing Both Selectivity and Coking-Resistance of a Single-Atom Pd 1 /C 3 N 4 Catalyst for Acetylene Hydrogenation

Decoupling Active Sites Enables Low-Temperature Semihydrogenation of Acetylene

Enhancing both selectivity and coking-resistance of a single-atom Pd1/C3N4 catalyst for acetylene hydrogenation

PdZn Intermetallic Nanostructure with Pd–Zn–Pd Ensembles for Highly Active and Chemoselective Semi-Hydrogenation of Acetylene

A Highly Active Catalyst Derived from CuO Particles for Selective Hydrogenation of Acetylene in Large Excess Ethylene

Carbon-confined Cu-Pd alloy nanoparticles as high-performance catalysts for acetylene selective hydrogenation

Pd Single‐Atom Catalysts on Nitrogen‐Doped Graphene for the Highly Selective Photothermal Hydrogenation of Acetylene to Ethylene

Adsorbate-Induced Structural Evolution of Pd Catalyst for Selective Hydrogenation of Acetylene

Alloyed PdCu Nanoparticles Within Siliceous Zeolite Crystals for Catalytic Semihydrogenation

AgPd and CuPd Catalysts for Selective Hydrogenation of Acetylene

Depositing Pd on the Outmost Surface of Pd 1 Ni/SiO 2 Single-Atom Alloy via Atomic Layer Deposition for Selective Hydrogenation of Acetylene

Anchoring ultrasmall Pd nanoparticles by bipyridine functional covalent organic frameworks for semihydrogenation of acetylene

Cu–Pd bimetal-decorated siloxene nanosheets for semi-hydrogenation of acetylene

Efficient Catalysis of Acetylene Semi-Hydrogenation through Synergistic Action of Supported Ionic Liquid-Nickel Catalyst

Catalyst Design for Acetylene Semi-Hydrogenation

Tuning electronic structure of palladium from wheat flour-derived N-doped mesoporous carbon for efficient selective hydrogenation of acetylene

Regulating Metal-Support Interactions of Pd/MgAl2O4 for Efficient Selective Hydrogenation of Acetylene