Abstract:The recycled powder produced in the process of crushing concrete and brick waste (C&BW) into recycled aggregate will cause environmental pollution. To realize the green full recycling of concrete and brick waste, the cement stabilization of crushed aggregate (CSCA) containing recycled brick-concrete composite micropowder (RBCP) and recycled brick-concrete composite aggregate (RBCA) is proposed. In this paper, RBCP, recycled brick-concrete composite fine aggregate (RBCFA), and recycled brick-concrete composite coarse aggregate (RBCCA) were the recycled materials from C&BW. The orthogonal test table was used to analyze the effects of the three recycled materials on the compaction characteristics, mechanical properties, and shrinkage behavior of CSCA at different dosages. The effects of RBCP, RBCCA, and RBCFA on the properties of CSCA are studied by variance analysis methods. On this basis, the micromorphology and the interface transition zone (ITZ) were studied for CSCA and the cement stabilization of crushed aggregate with RBCP, RBCFA, and RBCCA through scanning electron microscopy with energy dispersive spectroscopy (SEM/EDS), and the mechanism was revealed. The results indicate that the addition of RBCP and RBCA can increase the optimal water content while decreasing the optimal dry density of CSCA, and the influence of RBCCA on the optimal water content is greater than that of RBCFA. Three optimal composite replacement systems for CSCA, including 20% RBCP/20%RBCFA/40%RBCCA, are proposed and have the best mechanical and antishrinkage performance through the range analysis. Furthermore, the variance analysis test results show that RBCCA and RBCFA have the most significant effect on the compressive strength and shrinkage strain properties, while RBCP has the most significant effect on the bending tensile strength. It is found that RBCP played a filling effect and pozzolanic activity in the strength formation of CSCA. The SEM/EDS test shows that the CSCA with recycled materials produced the Ca/Si ratio in the interfacial zone between the cement paste and aggregate lower than the CSCA without recycled materials, the largest decline 52.83%. The research results of this paper can provide the potential application of RBCP and RBCA.

Mechanical Properties and Stress–strain Relationship in Axial Compression for Concrete with Added Glazed Hollow Beads and Construction Waste

Behavior of FRP-Confined Recycled Brick Aggregate Concrete under Monotonic Compression

Flexural Behavior and Durability Properties of Recycled Aggregate Concrete (RAC) Beams Subjected to Long-Term Loading and Chloride Attacks

High-strain Rate Compressive Behavior of Concrete Made with Substituted Coarse Aggregates: Recycled Crushed Concrete and Clay Bricks

Influence of Construction Conditions on Properties of Recycled Concrete

Characterizations and Quantification of Freeze-Thaw Behaviors of Recycled Brick Aggregate Concrete

Fundamental behaviour of recycled aggregate concrete - Overview I: strength and deformation

Mechanical Properties and ITZ Microstructure of Recycled Aggregate Concrete Using Carbonated Recycled Coarse Aggregate

Mechanical properties of recycled concrete with demolished waste concrete aggregate and clay brick aggregate

Triaxial compressive performance of recycled aggregate/glass sand concrete: Experimental study and mechanism analysis

Experimental Investigation of Properties of Concrete Containing Recycled Construction Wastes

Frost Resistance of Thermoinsulating Recycled-Aggregate Concretes Containing Glazed Hollow Beads

Mechanical properties of recycled aggregate concrete containing brick particles

Experimental study on the compressive strength, damping and interfacial transition zone properties of modified recycled aggregate concrete

The Mechanical Properties and Microstructure of Tailing Recycled Aggregate Concrete

[Malignant tumors of the peripheral nerve sheath (MPNST) after irradiation].

Study on Mechanical and Shrinkage Properties of High Belite Sulphoaluminate Cement-Based Green Recycled Aggregate Concrete

Study on stress–strain relationship and constitutive model of recycled aggregate concrete under axial cyclic compression

Investigating the Effects of Recycled Micropowder and Aggregate on the Properties of Cement Stabilization of Crushed Aggregate (CSCA)

Compressive performance and stress-strain relationship of geopolymer recycled brick aggregate concrete