Abstract:A new contactless bubble/slug velocity measurement method of the gas-liquid two-phase flow in small channels is proposed by extending the contactless conductivity detection technique to the contactless impedance detection (CID) technique. Two kinds of CID sensors with different constructions (tubular construction and radial construction) are developed to obtain the total impedance information (the real part, the imaginary part, and the amplitude) of the gas-liquid two-phase flow. Two bubble/slug velocity measurement systems with different constructions, the tubular three-electrode velocity measurement system and the radial four-electrode velocity measurement system, are developed. With the obtained total impedance information, three initial estimation values of the bubble/slug velocity are determined by the principle of the cross correlation velocity measurement. Then, with the real-time flow pattern identification result implemented by the fuzzy C-means, a corresponding velocity measurement model [which is the linear combination of the three initial estimation values of the bubble/slug velocity and is developed by the penalty function method and the Davidon-Fletcher-Powell algorithm] is applied to obtain the final bubble/slug velocity. Two groups of the bubble/slug velocity measurement system prototypes with three different inner diameters are developed. The bubble/slug velocity measurement experiments are carried out. The experimental results show that the proposed method is effective. For the two bubble/slug velocity measurement systems with different constructions, the maximum relative errors of the bubble/slug velocity measurement are all less than 4.5%. The research results also indicate that making full use of the total impedance information is an effective approach to improve the accuracy of the velocity measurement.

Response of Thermal Diffusion to Gas–liquid Stratified/wave Flow and Its Application in Measurement

Thermal diffusion response to gas–liquid slug flow and its application in measurement

Distribution law of Taylor bubble/liquid slug length in oil–gas–water slug flow and the measurement of gas/liquid flow rates based on thermal diffusion

Prediction Of Gas-Liquid Two-Phase Flow Rates Through A Vertical Pipe Based On Thermal Diffusion

A New Contactless Bubble/Slug Velocity Measurement Method of Gas–Liquid Two-Phase Flow in Small Channels

Online Parameters Measurement of Taylor Flow in Small Channels Using Optical Technique

Local instantaneous heat transfer characteristics around a rising single Taylor bubble and the temperature response of relatively thick pipe wall under local constant heat flux

Effect of the Heat Flow Distribution and Thermophysical Properties of the Pipe Wall and Fluid on the Wall Temperature Response to a Rising Taylor Bubble

A Method for Void Fraction Measurement of Bubble/slug Flow in Small Channels Based on Contactless Impedance Detection

Rapid On-Line and Non-Invasive Flow Rate Measurement of Gas–Liquid Slug Flow Based Only on Basic Differential Pressure Fluctuations

Flowrate measurement of vertical oil-gas-water slug flow based on basic temperature and differential pressure signals

Characterizations of Gas-Liquid Interface Distribution and Slug Evolution in a Vertical Pipe

Temperature fluctuation on pipe wall induced by gas–liquid flow and its application in flow pattern identification

Experimental Study on Near Wall Transport Characteristics of Slug Flow in a Vertical Pipe

Measurement of Gas Entrainment from Stationary Liquid Slug in Horizontal Tube with Double-Sensor Conductivity Probe

Characteristics of Gas-Liquid Slug Flow in Microchannel by Instantaneous Liquid Film Thickness Measurement

Simultaneous measurement of velocity profile and liquid film thickness in horizontal gas-liquid slug flow by using ultrasonic Doppler method

Measurement of Bubble Velocity Distribution in Horizontal Gas-Liquid Slug Flow by Single-Layer Wire-Mesh Sensor.

Experimental study on heat transfer and interfacial distribution of air-water slug flow in cooling process

Measurement of Gas-Liquid Flows with the Combination of Thermal Sensors and Conductance Sensor

An Experimental Study of the Flowrate Transients in Slug Flow