Abstract:Glycerol carbonate (GC) was synthesized by transesterification of glycerol with dimethyl carbonate (DMC) using calcium oxide (CaO) derived from eggshell as a catalyst. The best results of 96% glycerol conversion and 94% GC yield were achieved under the following reaction conditions: 0.08 mole ratio of CaO to glycerol, 1:2.5 mole ratio of glycerol to DMC, 60°C reaction temperature, and 3 hours reaction time. As expected, CaO showed deteriorated catalytic performance when recycling as observed by a rapid decrease in GC yield. This research showed that the active CaO phase first was converted to calcium methoxide (Ca[OCH3]2) and calcium diglyceroxide (Ca[C3H7O3]2) and finally to carbonate phase (CaCO3) which can be confirmed by XRD patterns. According to the phase transformation, the basicity decreased from 0.482 mmol/g to 0.023 mmol/g, and basic strength altered from strong basic strength (15.0 < H_ < 18.4) to weak basic strength (7.2 < H_ < 9.8), resulting in the lower catalytic activity of the consecutive runs. Despite the fact that the GC selectivity was almost 100%, the reaction products (methanol and GC) were not obtained in their stoichiometric ratio and their extents corresponded with that of the catalyst phase transformation to CaCO3. The mechanism of CaO catalyzed transesterification based on the condensation reaction of glycerol and catalyst was proposed, and in situ formation of water-derivative species was hypothesized as a cause of CaO transformation. CaO could react with DMC and water, generating methanol and CaCO3. This enabled unconventional monitoring of catalyst deactivation by checking if the mole ratio of methanol to GC was higher than 2:1 of its reaction stoichiometric ratio. It was also demonstrated that calcination of post-run catalyst at 900°C to CaO exhibited almost constant catalytic activity, and the mole ratio of methanol to GC was constant at its reaction stoichiometry (2:1) for at least 4 times use.

Monitoring reactive degree of biodiesel catalyzed by calcium oxide via gas chromatography

Mechanism of CaO catalyst deactivation with unconventional monitoring method for glycerol carbonate production via transesterification of glycerol with dimethyl carbonate

Effect of the Formation of Diglycerides/Monoglycerides on the Kinetic Curve in Oil Transesterification with Methanol Catalyzed by Calcium Oxide

FTIR spectroscopy analysis for monitoring biodiesel production by heterogeneous catalyst

Kinetics of glycerol esterification reaction

Zinc Glycerolate: an Unconventional Heterogeneous Catalyst for the Glycerolysis of Fatty Acids in Biodiesel Production

Solvent-Free Acetalization of Glycerol with N-Octanal Using Combined Brønsted Acid-Surfactant Catalyst

Structural study of mixed metal oxide catalysts comprising Mg, Ca, and Al used for upgrading biodiesel byproduct glycerol to glycerol carbonate

Catalytic Deoxygenation of Bio-Oil Model Compounds over Acid-Base Bifunctional Catalysts

Study of KOH/Al2O3 As Heterogeneous Catalyst for Biodiesel Production Via in Situ Transesterification from Microalgae.

Indirect Measurement of Variables in a Heterogeneous Reaction for Biodiesel Production

Calcium methoxide as a solid base catalyst for the transesterification of soybean oil to biodiesel with methanol

Calcium Ethoxide as a Solid Base Catalyst for the Transesterification of Soybean Oil to Biodiesel

Lipase-catalyzed solvent-free synthesis of monoglycerides from biodiesel-derived crude glycerol: Optimized using response surface methodology

Catalytic evaluation of eggshell‐based calcium methoxide over Al2O3 for biodiesel generation from waste cooking oil

Experimental and Quantum Chemical Calculations on the High-Efficiency Transesterification of Dimethyl Carbonate with Alcohol Catalyzed by Calcium Oxide

Novel porous CaO-MgO-promoting -Al2O3-catalyzed selective hydrogenation of oleic acid to green hydrocarbon fuels in biogasoline range with methanol as an internal hydrogen source

Optimized Biodiesel Production from Waste Cooking Oil (WCO) using Calcium Oxide (CaO) Nano-catalyst

Biodiesel Production Using MgO–CaO Catalysts via Transesterification of Soybean Oil: Effect of MgO Addition and Insights of Catalyst Deactivation

The role of impurities in the La2O3 catalysed carboxylation of crude glycerol

Comprehensive lipid hydrolysis observation in anaerobic digestion