Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

Experimental study on overall heat transfer coefficient of sea water and fresh water for horizontal-tube falling film evaporator

Heat transfer performance and bundle-depth effect in horizontal-tube falling film evaporators

A correlation of heat transfer for falling film evaporation on the horizontal tube with multiple-precision expansion method

Distribution of Heat Transfer Coefficient in Horizontal-Tube Falling Film Evaporator

Numerical study on the flow and heat-transfer characteristics of horizontal finned-tube falling-film evaporation: Effects of liquid column spacing and wettability

Numerical Study on Flow Heat Transfer Characteristics of Horizontal Tube Falling-Film Evaporator

Distribution of heat transfer coefficient in the vertical tube of falling film evaporator treating saline wastewater based on micro flow and experimental verification

Investigation on heat transfer performance of corrugated tubes in low-temperature multi-effect falling-film evaporation

Experimental Study of the Falling Film Evaporative Cooling on Horizontal Tubes Plates

Numerical analysis on flow and heat transfer of a tube bundle in a horizontal-tube falling film evaporator

Theoretical and Experimental Analyses of Two-Phase Flow Condensation Heat Transfer Inside the Horizontal Micro-Fin Tube

Study of Heat Transfer for Co2 Flow Boiling in Horizontal Small Diameter Tubes

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Experimental study on enhanced heat transfer tubes in falling film evaporation

Heat transfer of spray falling films over horizontal tubes with counter current airflows in an evaporative condenser

Falling Film Evaporation Of Water On Horizontal Configured Tube Bundles

Three-dimensional heat transfer coefficient distributions in horizontal tube falling film evaporation

Heat Transfer Characteristics of Falling Film Evaporation on Horizontal Tube Arrays

Experimental Investigation of Evaporation Heat Transfer Inside Horizontal Micro-Fin Tubes

Experimental study on heat transfer of horizontal-tube falling-film flow in deviated columnar mode

Experimental research on falling film flow and heat transfer characteristics outside the vertical tube