Abstract:At present, a few chemicals can be separated after further processing of high-temperature coal tar (HTCT) distillates, which have a lower utilization. However, hydrogenation to produce clean fuel oil has not been widely reported in literature. Thus, due to the use of new feedstocks and the implementation of more severe environmental legislations, deep hydrodesulfurization (HDS) of HTCT will face formidable challenges. A series of HDS experiments were performed in a continuous isothermal trickle bed reactor in which the reactor temperature was varied from 648 to 678 K, the pressure from 12 to 16 MPa, and the liquid hourly space velocity (LHSV) from 0.25 to 0.35 h-1, and hydrogen-to-oil ratio kept constant at 2000 L/L. Based on the experimental data, possible reaction pathways of HDS reaction were investigated, and a modified Langmuir-Hinshelwood (LH) HTCT desulfurization kinetic model was established. gPROMS software was used to obtain optimal kinetic parameters that are as follows: EA = 26,842, K 0 = 93,958, α = -1.14, n = 1.65, and m = 0.86. The model can well reproduce various working conditions and has better prediction accuracy. Some characteristics of HTCT HDS reactions were discovered; the reaction order (n) of HTCT HDS is slightly higher than that of crude oil and medium/low-temperature coal tar (M/LTCT), but the activation energy (EA) is relatively smaller. The established reactor model was used to predict the changes of the concentration of hydrogen, hydrogen sulfide, and sulfur compounds in the gas, liquid, and solid phases along the length of the reactor, respectively. The model was also used to predict the effects of pressure, temperature, and LHSV on the conversion rate of sulfur and catalyst effectiveness factors. The results showed that the LHSV has a greater impact on the conversion rate, and the pressure and temperature are less pronounced at high-severity operating conditions; the effectiveness factor is significantly smaller than that of other HDS processes, temperature has a greater effect on the effectiveness factor, followed by pressure and LHSV. The conclusion can provide a basis for further understanding the HTCT hydrotreating process.

Kinetic Parameter Calculation and Trickle Bed Reactor Simulation Based on Pilot-Scale Hydrodesulfurization Test of High-Temperature Coal Tar

Modelling and Simulation of Industrial Trickle Bed Reactor Hydrotreating for Whole Fraction Low-Temperature Coal Tar Simultaneous Hydrodesulfurisation and Hydrodenitrification

Kinetic parameter estimation and simulation of trickle-bed reactor for hydrodesulfurization of whole fraction low-temperature coal tar

Kinetic Parameter Estimation and Reactor Simulation of Full-Range Low Temperature Coal Tar During Hydrodeasphaltenization over Ni–Mo/γ-Al2O3

Optimization of Processing Parameters and Macrokinetics for Hydrodesulfurization of Coal Tar

Kinetics Study and Reactor Simulation of Full-Range Low-Temperature Coal Tar During Hydrodeoxygenation Process

Kinetic Parameter Estimation and Simulation of Trickle-Bed Reactor for Hydrodenitrogenation of Whole-Fraction Low-Temperature Coal Tar

Kinetic Model for Low-Temperature Coal Tar Hydrorefining

Intensification of Deep Hydrodesulfurization Through a Two-stage Combination of Monolith and Trickle Bed Reactors

Coupling Non-Isothermal Trickle-Bed Reactor with Catalyst Pellet Models to Understand the Reaction and Diffusion in Gas Oil Hydrodesulfurization

Study on the Preparation of Clean Liquid Fuel by Wide Fraction High-Temperature Coal Tar Deep Hydro-Upgrading on a Pilot Plant Trickle Bed Reactor

Lumped Kinetic Simulation of Hydrodenitrogenation for Full-Range Middle-Low Temperature Coal Tar

Upgrading Siberian (russia) Crude Oil by Hydrodesulfurization: Kinetic Parameter Estimation in a Trickle-Bed Reactor

Optimization of Reaction Variables and Macrokinetics for the Hydrodeoxygenation of Full Range Low Temperature Coal Tar

Modeling the Hydrotreatment of Full Range Medium Temperature Coal Tar by Using a Lumping Kinetic Approach

Pilot-scale study of upgrading a low temperature coal tar distillate for the production of clean fuels

Lumped Kinetic Model for the Hydrodeoxygenation of Full-Range Middle-Low Temperature Coal Tar

Catalytic kinetics for ultra-deep hydrodesulfurization of diesel

Kinetics for Hydrodesulfurization of Coal Tar

Application of Artifical Neural Networks to Hydrodesulfurization of Gasoline and Diesel Mixtures

Production of Clean Fuels by Catalytic Hydrotreating a Low Temperature Coal Tar Distillate in a Pilot-Scale Reactor