Abstract:The incorporation of ethanol into hydrocarbon fuels for use is attracting increasing interest and it is necessary to investigate its inherent flame instability for better application in combustion units. The instability of hydrogen-methane-ethanol spherically expanding flame has been investigated at an initial temperature of 400 K, initial pressures of (2–4 bar), ethanol fraction of (20%, 50%, 80%), and equivalence ratios ( Ф ) of (0.7–1.4) using the constant volume combustion chamber (CVCC). High-speed schlieren technology was used to record flame propagation images. The effects of hydrodynamic and thermal-diffusion effect on the inherent instability of the flame were investigated. As the ethanol ratio increased, the hydrodynamic effect was enhanced. The thermal-diffusion effect was discovered to stabilize the flame surface under all conditions, as judged jointly by the effective Lewis number and the critical Lewis number. The critical conditions (critical radius and Peclet number) at the onset of unstability were evaluated, and it was found that the flames were more prone to flame instability at higher pressures. The critical Peclet number increased with the increase in the equivalence ratio when the ethanol ratio was 20%, and showed the opposite trend when the ethanol ratio was 50% and 80%. In addition, as the ethanol ratio increases, the stability of the lean mixtures flame increases, while the rich mixtures flame suffers from early onset of instability. The theoretical and experimental results were consistent, with some differences at Ф = 1.4. An empirical correlation formula for the critical Peclet number ( Pec ) and Markstein number ( M b ) was further proposed ( Pec = 18.03 M b +214.78). Finally, the Karlovitz number was used to study the instability behavior of the flame. The critical Karlovitz number ( Ka c ) decreased with increasing M b and the tendency of the flame to suffer from instability diminished, and the following correlation was obtained Kac=0.05635×e−0.13852Mb . Furthermore, the flame was more unstable in rich mixtures, this was consistent with the conclusion of instability derived from the critical radius.

Numerical Study and Cellular Instability Analysis of E30-air Mixtures at Elevated Temperatures and Pressures

Measurements of Laminar Flame Speeds and Flame Instability Analysis of E30-air Premixed Flames at Elevated Temperatures and Pressures

Experimental and Numerical Study on the Effect of Hydrogen Addition on Laminar Burning Velocity of Ethanol-Air Mixtures

Experimental Investigation on the Effect of Equivalence Ratio on the Development of Cellular Structure of E30-air Mixture

Experiment Study on Major and Intermediate Species of Ethanol/N-Heptane Premixed Flames

Investigation of cellular characteristics of hydrogen-ethanol flame at elevated temperatures and pressures

Investigation of cellularization characteristics of hydrogen-methane-ethanol expanding spherical flame at elevated pressures

Numerical and Theoretical Investigation of Ethanol/air Flame Instability

Laminar burning Velocities, Markstein numbers and cellular instability of spherically propagation Ethane/Hydrogen/Air premixed flames at elevated pressures

Study on Laminar Burning Characteristics of Premixed High-Octane Fuel−Air Mixtures at Elevated Pressures and Temperatures

Study on Premixed Laminar Combustion Characteristics of Ethanol-Air-Diluted Mixtures at Elevated Pressures and Temperatures

A numerical and comparative study of the laminar combustion characteristics and kinetics of dimethyl ether and ethanol flames at elevated temperature

Experimental and theoretical investigation on cellular instability of methanol/air flames

Flame Instability Analysis of Diethyl Ether-Air Premixed Mixtures at Elevated Pressures

The Temperature and Pressure Dependencies of Propagation Characteris-tics for Premixed Laminar Ethanol-Air Flames

Experimental and Numerical Studies on Laminar Premixed Flames of Ethanol–Water–Air Mixtures

Laminar and kinetic burning characteristics of ethanol/methane/hydrogen fuel: experimental and numerical analysis

Experimental and Numerical Studies on the Explosion Characteristics of Ethanol–Air Mixtures under Aviation Conditions

Measurements of Laminar Burning Velocities and Markstein Lengths Ofn-Butanol−air Premixed Mixtures at Elevated Temperatures and Pressures

Experimental Study on the Premixed Laminar Flames for Ethanol-Air Mixtures

Numerical Study of Influence of Initial Pressures and Temperatures on the Lower Flammability Limits of Oxygenated Fuels in Air