Abstract:An enhancement for magnetoelectric (ME) effects is studied in a three-phase ME architecture consisting of two magnetostrictive Terfenol-D (Tb(0.3)Dy(0.7)Fe(1.92)) plates, a piezoelectric PZT (Pb(Zr,Ti)O3) plate, and a pair of shape-optimized FeCuNbSiB nanocrystalline alloys. By modifying the conventional shape of the magnetic flux concentrator, the shape-optimized flux concentrator has an improved effective permeability (μ(eff)) due to the shape-induced demagnetizing effect at its end surface. The flux concentrator concentrates and amplifies the external magnetic flux into Terfenol-D plate by means of changing its internal flux concentrating manner. Consequently, more flux lines can be uniformly concentrated into Terfenol-D plates. The effective piezomagnetic coefficients (d(33m)) of Terfenol-D plate and the ME voltage coefficients (α(ME)) can be further improved under a lower magnetic bias field. The dynamic magneto-elastic properties and the effective magnetic induction of Terfenol-D are taken into account to derive the enhanced effective ME voltage coefficients (α(ME,eff)), the consistency of experimental results and theoretical analyses verifies this enhancement. The experimental results demonstrate that the maximum d(33m) in our proposed architecture achieves 22.48 nm/A under a bias of 114 Oe. The maximum α(ME) in the bias magnetic range 0-900 Oe reaches 84.73 mV/Oe under the low frequency of 1 kHz, and 2.996 V/Oe under the resonance frequency of 102.3 kHz, respectively. It exhibits a 1.43 times larger piezomagnetic coefficient and a 1.87 times higher ME voltage coefficient under a smaller magnetic bias of 82 Oe than those of a conventional Terfenol-D/PZT/Terfenol-D composite. These shape-induced magnetoelectric behaviors provide the possibility of using this ME architecture in ultra-sensitive magnetic sensors.

Microbridge-Structured Magnetoelectric Sensor Array Based on PZT/FeCoSiB Thin Films

Micro-Sensors with Giant magnetoelectric Coefficient

Fabrication And Characterization Of All-Thin-Film Magnetoelectric Sensors

Micro Magnetic Field Sensor Based on Terfenol-D/Pzt/Terfenol-D Magnetoelectric Composites

A Novel Structure Magnetoelectric Composite for Magnetic Sensor

Enhanced Magnetoelectric Effect in Ferromagnetic–elastic–piezoelectric Composites

A Flexible Magnetic Field Sensor Based on PZT/CFO Bilayer via van der Waals Oxide Heteroepitaxy

Recent Progress in Devices Based on Magnetoelectric Composite Thin Films

Magnetic Sensor Employing Piezoelectric Ceramic/Rare-Earth Iron Alloy/High-Permeability Fecunbsib Composite

The Giant Magnetoelectric Effect in Fe73.5Cu1Nb3Si13.5B9/PZT Thick Film Composites

Magnetoelectric Performances in Composite of Piezoelectric Ceramic and Ferromagnetic Constant-Elasticity Alloy

A high-sensitivity zero-biased magnetoelectric sensor using five-phase laminate composites based on FeCoV nanocrystalline soft magnetic alloy

Ultrasensitive flexible magnetoelectric sensor

Resonant Magnetoelectric Effect in Winglike Magnetoelectric Composites of Fe-Based Nanocrystalline FeCuNbSiB Alloy and Piezoelectric Ceramic Pb(Zr,Ti)O3 with Middle Bonding

Magnetic Sensors Based on Magnetoelectric Laminate Multiferroic Heterostructures with Dual-Peak Phenomenon

Enhanced Magnetoelectric Effects in Composite of Piezoelectric Ceramics, Rare-Earth Iron Alloys, and Shape-Optimized Nanocrystalline Alloys

Magnetoelectric Transducer Employing Piezoelectric Ceramic/Ferromagnetic Alloy/High-Permeability FeCuNbSiB Composite

Enhanced Multipeak Magnetoelectric Effects in Ferromagnetic/Ferroelectric Composite with H-Shaped Elastic Substrate

Magnetic-Field Induced Electric Response of Simple Magnetoelectric Composite Rods

Multiple Broadband Magnetoelectric Response in Terfenol-D/PZT Structure

Magnetoelectric Effect in Shear-Mode Pb(Zr,Ti)O3/NdFeB Composite Cantilever