Abstract:The magnetoelectric effect (ME) is an important strain mediated-phenomenon in a ferromagnetic-piezoelectric composite for a variety of sensors and signal processing devices. A bias magnetic field, in general, is essential to realize a strong ME coupling in most composites. Magnetic phases with (i) high magnetostriction for strong piezomagnetic coupling and (ii) large anisotropy field that acts as a built-in bias field are preferred so that miniature, ME composite-based devices can operate without the need for an external magnetic field. We are able to realize such a magnetic phase with a composite of (i) barium hexaferrite (BaM) with high magnetocrystalline anisotropy field and (ii) nickel ferrite (NFO) with high magnetostriction. The BNx composites, with (100 - x) wt.% of BaM and x wt.% NFO, for x = 0-100, were prepared. X-ray diffraction analysis shows that the composites did not contain any impurity phases. Scanning electron microscopy images revealed that, with an increase in NFO content, hexagonal BaM grains become prominent, leading to a large anisotropy field. The room temperature saturation magnetization showed a general increase with increasing BaM content in the composites. NFO rich composites with x ≥ 60 were found to have a large magnetostriction value of around -23 ppm, comparable to pure NFO. The anisotropy field HA of the composites, determined from magnetization and ferromagnetic resonance (FMR) measurements, increased with increasing NFO content and reached a maximum of 7.77 kOe for x = 75. The BNx composite was cut into rectangular platelets and bonded with PZT to form the bilayers. ME voltage coefficient (MEVC) measurements at low frequencies and at mechanical resonance showed strong coupling at zero bias for samples with x ≥ 33. This large in-plane HA acted as a built-in field for strong ME effects under zero external bias in the bilayers. The highest zero-bias MEVC of ~22 mV/cm Oe was obtained for BN75-PZT bilayers wherein BN75 also has the highest HA. The Bilayer of BN95-PZT showed a maximum MEVC ~992 mV/cm Oe at electromechanical resonance at 59 kHz. The use of hexaferrite-spinel ferrite composite to achieve strong zero-bias ME coupling in bilayers with PZT is significant for applications related to energy harvesting, sensors, and high frequency devices.

Magnetic-Field Induced Electric Response of Simple Magnetoelectric Composite Rods

Magnetoelectric Properties of Composites of Single Pb(Zr,Ti)O3 Rods and Terfenol‐D/Epoxy with a Single‐Period of 1‐3‐type Structure

A Novel Cylindrical Torsional Magnetoelectric Composite Based Ond15shear-Mode Response

Magnetoelectric Effect in Shear-Mode Pb(Zr,Ti)O3/NdFeB Composite Cantilever

Magnetoelectric effect in layered ferrite/PZT composites. Study of the demagnetizing effect on the magnetoelectric behavior

Magnetoelectric Properties of Multiferroic Composites with Pseudo 1-3 Type Structure

Giant magnetoelectric effect under high bias fields in cylindrical bilayered Ni-PZT composites

Magnetoelectric Effect in Ni-PZT-Ni Cylindrical Layered Composite Synthesized by Electro-deposition

Using magnetoelectric effect to reveal magnetization behavior of bulk and heavy ferromagnetic materials

A Novel Structure Magnetoelectric Composite for Magnetic Sensor

Magnetic-Field-Orientation Dependent Magnetoelectric Effect in FeBSiC/PZT/FeBSiC Composites

Micro Magnetic Field Sensor Based on Terfenol-D/Pzt/Terfenol-D Magnetoelectric Composites

Self-biased and Wide Resonance Band Magnetoelectric Effect in Series-Connected SrFe12O19/Metglas/Pb(Zr, Ti)O3composites

A New Magnetoelectric Resonance Mode in Bilayer Structure Composite of PZT Layer and Terfenol-D/epoxy Layer

Giant Magnetoelectric Effect of A Hybrid of Magnetostrictive and Piezoelectric Composites

Converse Magnetoelectric Effect in Ni(Terfenol-D)/Pb(Zr,Ti)O-3 Bilayer-Laminated Composite

Resonance Magnetoelectric Effect in Bulk Composites of Lead Zirconate Titanate and Nickel Ferrite

Magnetodielectric Effect and Electric-Induced Magnetic Permeability in Magnetoelectric Laminate Composite under Low Inspiring Signal

The Study of Magnetoimpedance Effect for Magnetoelectric Laminate Composites with Different Magnetostrictive Layers

A Novel Spinel Ferrite-Hexagonal Ferrite Composite for Enhanced Magneto-Electric Coupling in a Bilayer with PZT

A Dual-Peak Phenomenon of Magnetoelectric Coupling in Laminated Terfenol-D/Pzt/Terfenol-D Composites