Abstract:The magnetoelectric effect (ME) is an important strain mediated-phenomenon in a ferromagnetic-piezoelectric composite for a variety of sensors and signal processing devices. A bias magnetic field, in general, is essential to realize a strong ME coupling in most composites. Magnetic phases with (i) high magnetostriction for strong piezomagnetic coupling and (ii) large anisotropy field that acts as a built-in bias field are preferred so that miniature, ME composite-based devices can operate without the need for an external magnetic field. We are able to realize such a magnetic phase with a composite of (i) barium hexaferrite (BaM) with high magnetocrystalline anisotropy field and (ii) nickel ferrite (NFO) with high magnetostriction. The BNx composites, with (100 - x) wt.% of BaM and x wt.% NFO, for x = 0-100, were prepared. X-ray diffraction analysis shows that the composites did not contain any impurity phases. Scanning electron microscopy images revealed that, with an increase in NFO content, hexagonal BaM grains become prominent, leading to a large anisotropy field. The room temperature saturation magnetization showed a general increase with increasing BaM content in the composites. NFO rich composites with x ≥ 60 were found to have a large magnetostriction value of around -23 ppm, comparable to pure NFO. The anisotropy field HA of the composites, determined from magnetization and ferromagnetic resonance (FMR) measurements, increased with increasing NFO content and reached a maximum of 7.77 kOe for x = 75. The BNx composite was cut into rectangular platelets and bonded with PZT to form the bilayers. ME voltage coefficient (MEVC) measurements at low frequencies and at mechanical resonance showed strong coupling at zero bias for samples with x ≥ 33. This large in-plane HA acted as a built-in field for strong ME effects under zero external bias in the bilayers. The highest zero-bias MEVC of ~22 mV/cm Oe was obtained for BN75-PZT bilayers wherein BN75 also has the highest HA. The Bilayer of BN95-PZT showed a maximum MEVC ~992 mV/cm Oe at electromechanical resonance at 59 kHz. The use of hexaferrite-spinel ferrite composite to achieve strong zero-bias ME coupling in bilayers with PZT is significant for applications related to energy harvesting, sensors, and high frequency devices.

A Novel Cylindrical Torsional Magnetoelectric Composite Based Ond15shear-Mode Response

Magnetoelectric Effect in Shear-Mode Pb(Zr,Ti)O3/NdFeB Composite Cantilever

Magnetic-Field Induced Electric Response of Simple Magnetoelectric Composite Rods

Magnetoelectric Effect in Ni-PZT-Ni Cylindrical Layered Composite Synthesized by Electro-deposition

Giant magnetoelectric effect under high bias fields in cylindrical bilayered Ni-PZT composites

A New Magnetoelectric Resonance Mode in Bilayer Structure Composite of PZT Layer and Terfenol-D/epoxy Layer

Giant Magnetoelectric Effect of A Hybrid of Magnetostrictive and Piezoelectric Composites

A Novel Spinel Ferrite-Hexagonal Ferrite Composite for Enhanced Magneto-Electric Coupling in a Bilayer with PZT

Magnetoelectric Effect in Stretch-Shear Mode Self-Biased LiNbO3 Based Composite with High-Frequency Resonant Response

Resonance Magnetoelectric Effect in Radially Polarized Long Cylindrical Composite Structures

Self-biased and Wide Resonance Band Magnetoelectric Effect in Series-Connected SrFe12O19/Metglas/Pb(Zr, Ti)O3composites

Resonance Magnetoelectric Effect in Bulk Composites of Lead Zirconate Titanate and Nickel Ferrite

Converse Magnetoelectric Effect in Ni(Terfenol-D)/Pb(Zr,Ti)O-3 Bilayer-Laminated Composite

Magnetoelectric effect in layered ferrite/PZT composites. Study of the demagnetizing effect on the magnetoelectric behavior

Enhanced Magnetoelectric Coupling for Embedded Multiferroic Composites Via Planar Compressive Stress

Self-biased magnetoelectric sensor operating in d 36 face-shear mode

Magnetoelectric Effect in Magnetostrictive/piezoelectric Laminated Composite Operating in Shear-Shear Mode

Magnetoelectric properties in Ni/Pb(Zr,Ti)O 3 /FeCo laminated composites with different extensional strain modes

Using magnetoelectric effect to reveal magnetization behavior of bulk and heavy ferromagnetic materials

Giant Magnetoelectric Effect in Sintered Multilayered Composite Structures

Numerical modeling of the magnetoelectric effect in magnetostrictive piezoelectric bilayers