Modeling of the Coal Particle Behavior in an Ultra-Supercritical Boiler with Large Eddy Simulation

Haoshu Shen,Yang Zhang,Yuxin Wu,Minmin Zhou,Hai Zhang,Guangxi Yue

DOI: https://doi.org/10.1115/1.4046138

2020-01-01

Journal of Energy Resources Technology

Abstract:Large eddy simulation (LES) is becoming a promising tool for the design and retrofit of utility boilers. It explicitly calculates the large-scale eddies which play an important role in the particle behavior inside the boilers. An ultra-supercritical tangentially fired boiler was simulated under the boiler maximum continuous rate (BMCR) condition by LES. The particle phase was tracked by the simplified direct quadrature method of moments in the Eulerian framework. Five particle sizes were adopted to represent the wide particle size distribution. The predicted gas velocities were in good agreement with the thermal calculation. The LES results showed that the particles were more likely to be concentrated in the main burner zone while quickly dispersed in the over fire air (OFA) zone. A theoretical analysis found that the particle Stokes number based on the sub-grid scale was much smaller than one. The particles would behave as tracers for the eddies resolved by LES. However, some differences between the small and large particles were observed in the particle number density distributed along the vertical and horizontal directions. It meant that the inertial effects on the particle motion cannot be neglected.