Abstract:A combined steady-state and transient approach is employed to investigate the corrosion behavior of X80 pipeline steel in carbon dioxide-saturated brines. Continuous bubbling of carbon dioxide into a test vessel with 1 liter capacity is performed to simulate the flowing condition. The measurement of time-dependent open-circuit potential, polarization resistance, and electrochemical impedance spectroscopy (EIS) is conducted to interpret the evolution of dissolution processes at the corroding interface. Three distinguishing stages are observed at a temperature of 60 °C during a whole exposure of 144 h. Analyses mainly based on the consecutive mechanism show that after the first stage of the active-adsorption state, the anodic reaction is significantly retarded by the accumulation of (FeOH)ads on the iron surface, causing a sharp increase in the polarization resistance and the open-circuit potential, as well as the disappearance of the inductive loop in EIS. At the third stage, the formation of the corrosion product layer similarly reduces both the anodic and cathodic reactions, which arouses a linear increase in the polarization resistance with time and a capacitive loop in EIS but changes the open-circuit potential slightly. An increase in salinity in this study reduces the polarization resistance and enhances iron dissolution by promoting the formation and relaxation of (FeOH)ads; however, it brings little change to the developing time of the three stages obviously. At a low temperature of 20 °C, a protective product layer is not observed in carbon dioxide-saturated brine, and the dissolution of iron is mainly under activation control during the whole exposure. A notable enlarged polarization resistance and different interfacial processes are observed in an alkaline solution compared with those in acidic environments, which is deduced to be resulted from an impedance in the relaxation of (FeOH)ads by increasing pH. The observations in this study support well that the iron dissolution reaction at the initial stage exposed in carbon dioxide aqueous environments is dominant by water adsorption on the iron surface, and further investigation should be performed on the role that carbon dioxide plays in the evolution of corrosion products and the formation of a protective film on the steel surface by taking into account local water chemistry.

Understanding the Propagation of Nonuniform Corrosion on a Steel Surface Covered by Marine Sand

The Impact of Oxygen Availability on Steel Corrosion Considering the Self-Balance Between Anodic and Cathodic Corrosion Cells

Corrosion inhibition of deposit-covered X80 pipeline steel in seawater containing Pseudomonas stutzeri.

Corrosion Behavior of X80 Pipeline Steel in Alkaline Sand Soil with Saturated Water

Experimental Investigation on Corrosion Behavior of X80 Pipeline Steel under Carbon Dioxide Aqueous Conditions

Evaluation of corrosion and erosion–corrosion behavior of X65 pipeline steel in flowing CO2-saturated electrolyte

Role of Fe oxide in the underdeposit corrosion of pipeline steel in oilfield produced water containing SRB

Corrosion Behavior of a Low-Carbon Steel in Simulated Marine Splash Zone

Effect of Microstructures on Corrosion of X80 Pipeline Steel in an Alkaline Soil

The effect of CaCO 3 deposit on corrosion of NaCl - Alkali/ surfactant/ polymer produced water pipeline

Corrosion Resistance of X80 Pipeline Steel in Simulated Solution of Seaside Saline-Alkali Soil

Understanding the interaction between erosion and corrosion of pipeline steel in acid solution of different pH

Corrosion Inhibition Properties of Corrosion Inhibitors to under-Deposit Corrosion of X65 Steel in CO2 Corrosion Conditions

Corrosion Behavior of X65 Pipeline Steel: Comparison of Wet–dry Cycle and Full Immersion

Influence of anion and sulfate-reducing bacteria on the stress corrosion behavior and mechanism of X70 steel in a marine mud environment

Corrosion Behavior of the Steel Used As a Huge Storage Tank in Seawater

The Influence of Microstructures on the Corrosion Properties of X80 Pipeline Steel in Near-Neutral Ph Soil

Corrosion Behavior of Long-Time Immersed Rusted Carbon Steel in Flowing Seawater

Non-uniform Corrosion Characteristics of the Steel Pipe Pile Exposed to Marine Environments

Study on Electrochemical Corrosion Behavior of X80 Pipeline Steel in Luoyang Soil with Saturated Water

Study on corrosion behavior and mechanism of AISI 4135 steel in marine environments based on field exposure experiment