Abstract:The study investigated the effects of pre-treated olivine in dual bed steam gasification (DBSG) of biomass compost in order to produce H-2 enriched synthesis gas with significantly reduced tar formation. The DBSG employed circulating fluidized bed (CFB) of silica sand as first stage and fixed catalytic bed of pre-treated olivine as second stage. The mixed biomass compost contained 15-20 wt. % of agri-residues (mainly wheat straw) and 80-85 wt. % of cow manure. The study compared the synthesis gas distribution and tar reductions using pre-treated olivine in the DBSG scheme with Ni-Al based DBSG scheme. The effects of operating condition on the synthesis gas distribution and tar formation are studied such as: (i) effect of steam to biomass ratio, (ii) effects of relative oxidation (relox), (iii) operating temperature of the reactor, (iv) performance and comparison of employed catalysts, and (v) yield of synthesis gas together with carbon conversion efficiency. Experimental analysis showed that H-2 concentration obtained from pre-treated olivine based DBSG is considerably higher than H-2 produced from compared gasification schemes. The H-2 production is favoured at higher temperatures and higher SBR under the influence of pre-treated olivine catalyst. However, the conditions are less advantageous for the production of CO and CH4. Among all experiments, the synthesis gas composition obtained at SBR = 1.40 and at 800 degrees C consisted of highest H-2 concentration (35 vol.% d.n.f) in the pre-treated olivine DBSG. Higher steam to biomass ratio (SBR) resulted in lower cold gas energy efficiency and lower heating value of the synthesis gas mainly due to large steam content in the gas. The tar removal efficiency of 98% is achieved with the pre-treated olivine DBSG system. The total tar content is significantly reduced (approximate to 40%) in the DBSG with pre-treated olivine. Higher relative oxidation resulted in increased concentration of CO2 in the synthesis gas due to increased partial oxidation of organic matter in the gasifier. The pre-treated olivine catalyst in the DBSG consistently promoted the process of steam reforming and tar cracking and thus improved the quality of the syngas by limiting the tar contents. (C) 2016 Hydrogen Energy Publications LLC. Published by Elsevier Ltd. All rights reserved.

Effects of Ionic Liquid-Assisted Pretreatment of Heavy Metal-Contaminated Biomass on the Yield and Composition of Syngas Production Using Noncatalytic and Catalytic Pyrolysis and Gasification Processes

Effective Pretreatment of Heavy Metal-Contaminated Biomass Using a Low-Cost Ionic Liquid (triethylammonium Hydrogen Sulfate): Optimization by Response Surface Methodology–Box Behnken Design

Effects of Ionic Liquid Pretreatment on Pyrolysis Characteristics of a High-Sulfur Bituminous Coal

The Deleterious Effect of Inorganic Salts on Hydrocarbon Yields from Catalytic Pyrolysis of Lignocellulosic Biomass and Its Mitigation

Ionic Liquid-Assisted Production of Biochar with High Cu2+ Removal Efficiency: Effect of Pyrolysis Temperature and CaCO3 Content in Biomass

Ionic Liquid-Catalyzed Hydrothermal Carbonization of Sewage Sludge: Effect of Residence Time and Liquid Phase Circulation on Hydrochar Characteristic

Ionic liquid catalyzed low-temperature hydrothermal carbonization of sewage sludge to produce hydrochar with low heavy metal content and positive energy recovery

Effect of the Water Washing Pretreatment on Biomass Pyrolysis in CO2 Atmosphere

Effect of the water washing pretreatment on biomass pyrolysis in CO 2 atmosphere

An Experimental Study on Hydrogen Enriched Gas with Reduced Tar Formation Using Pre-Treated Olivine in Dual Bed Steam Gasification of Mixed Biomass Compost

Alkali metal bifunctional catalyst-sorbents enabled biomass pyrolysis for enhanced hydrogen production

Simultaneous improvement in qualities of bio-oil and syngas from catalytic pyrolysis of rice husk by demineralization

Effects of different pretreatment methods on millet straw and millet bran for fuel properties and pyrolysis bio-oil

Investigation of a novel acid-catalyzed ionic liquid pretreatment method to improve biomass enzymatic hydrolysis conversion

In-situ plasma assisted lithium-ion battery cathodes to catalytically pyrolyze lignin for H 2 -rich syngas production

Effects of Pretreatment with Ionic Liquids on Cellulose Hydrolysis under Hydrothermal Conditions

Simultaneous optimizations of heavy metal immobilizations, products, temperature, and atmosphere dependency by acid pretreatment-assisted pyrolysis and gasification of hyperaccumulator ( Pteris vittate L.) biomass

Effect of Ionic Liquid Pretreatment on the Composition, Structure and Biogas Production of Water Hyacinth (eichhornia Crassipes)

Effects of Char and Volatiles Extraction on the Performance of Dual Bed Pyrolysis Gasification System

Synergistic optimization of syngas quality and heavy metal immobilization during continuous microwave pyrolysis of sludge: Competitive relationships, reaction mechanisms, and energy efficiency assessment

Mechanistic Insight into the Effect of Hydrothermal Treatment of Sewage Sludge on Subsequent Pyrolysis: Evolution of Volatile and Their Interaction with Pyrolysis Kinetic and Products Compositions