Abstract:The SO2/NOX pollution in the flue gas of non-ferrous smelting is increasingly serious. At the same time, the accumulation of red mud (RM) in the aluminum industry and phosphorus sludge (PS) in the yellow phosphorus industry has caused serious harm to the environment. To remove SO2 and NOX from the non-ferrous smelting flue gas and realize the resource utilization of the above two solid wastes, an ultrasonic field was used in this study to strengthen the PS excited O3 process and RM wet desulfurization and denitrification process. In the process of O3 excitation, the response surface method (RSM) is used to obtain the optimal O3 excitation concentration, and the optimal reaction conditions are designed based on the response surface optimization model: T is 53.226 °C, power density is 0.4 W/cm2, PS concentration is 51.433 g/L, O3 formation concentration up to 250 ppm or more, which provides a theoretical basis for subsequent desulfurization and denitrification steps. It is proved that this study can replace the expensive traditional O3 generator and provide a basis for NOX removal in the following process. In addition, the optimum experimental conditions of ultrasonic enhanced RM desulfurization and denitrification process were also explored. Under ultrasonic frequency of 28 kHz, ultrasonic power density of 0.4 W/cm2, T of 50 °C, RM concentration of 15 g/L, and stirring intensity of 1000 rpm, the desulfurization efficiency of the reaction system can be maintained above 95 % within 250 min, and the denitrification efficiency can be maintained above 90 % within 250 min. The effect of desulfurization and denitrification in this study is much better than that of traditional methods. Finally, the reaction mechanism of ultrasonic enhanced O3 excitation and RM wet desulfurization and nitrogen removal was discussed by combining adsorption thermodynamics, isotherm, and kinetics. The results showed that the OH· free radicals generated by ultrasonic cavitation and the physical effects brought by emulsification had significant promoting effects.

Tributyl Phosphate Additive Enhancing Catalytic Absorption of NO2 for Simultaneous Removal of SO2/NOx in Wet Desulfurization System

Novel Method for High-Performance Simultaneous Removal of NOx and SO2 by Coupling Yellow Phosphorus Emulsion with Red Mud

A Superior Liquid Phase Catalyst for Enhanced Absorption of NO2 Together with SO2 after Low Temperature Ozone Oxidation for Flue Gas Treatment

Simultaneous Removal of SO2 and NO by FeII(EDTA) Solution: Promotion of Mn Powder and Mechanism of Reduction

Effective Absorption Mechanism of SO2 and NO2 in the Flue Gas by Ammonium-Bromide-Based Deep Eutectic Solvents

High Efficient Removal Of So2 And No Of Flue Gas In A Single Fluidized Bed Reactor

An Adaptive Sorbent for the Combined Desulfurization/Denitration Process Using a Powder-Particle Fluidized Bed

Integrated Tests for Removal of Nitric: Oxide with Iron Thiochelate in Wet Flue Gas Desulfurization Systems

Removal of Nitric Oxide from Flue Gas with Iron Thiochelate Aqueous Solution in A Turbulent Contact Absorber

Synergistic Adsorption and in Situ Catalytic Conversion of SO2 by Transformed Bimetal-Phenolic Functionalized Biomass.

Mechanistic Study on the Removal of NO 2 from Flue Gas Using Novel Ethylene Glycol-tetrabutylammonium Bromide Deep Eutectic Solvents

Ultrasonic-enhanced Phosphorus Sludge Excited O3 Coupled Red Mud Simultaneous Desulfurization and Denitrification

Fe-doped CeTiO x catalysts facilitate the oriented oxidation of NO to achieving simultaneous desulfurization and denitration in a WFGD system

Improved activity and significant SO2 tolerance of Sb-Pd-V oxides on N-doped TiO2 for CB/NOx synergistic degradation.

Simultaneous removal of SO2 and NOx by combination of ozone oxidation and Na2S2O3solution spray

Enhanced Desulfurization by Tannin Extract Absorption Assisted by Binuclear Sulfonated Phthalocyanine Cobalt Polymer: Performance and Mechanism

Simultaneous Absorption of SO2 and NO from Flue Gas Using Ultrasound/fe2+/heat Coactivated Persulfate System

Removal of NO and SO_2 from Flue Gas by Wet Scrubbing Using Aqueous NaClO Solution

Simultaneous removal of SO2 and NOx from flue gas by phosphorus sludge: the performance and absorption mechanism

Simultaneous Removal of Sulfur Dioxide and Nitrogen Oxide from Flue Gas by Phosphorus Sludge: the Performance and Absorption Mechanism

Boosting SO2-Resistant NOx Reduction by Modulating Electronic Interaction of Short-Range Fe-O Coordination over Fe2O3/TiO2 Catalysts