Effects of Fuel/air Distribution on the NH3/CH4 Flame Stability Limit and NOx Emission in a Dual-Annular Burner
Yipeng Li,Jinguo Sun,Qian Huang,Reinhold Kneer,Shuiqing Li
DOI: https://doi.org/10.1016/j.combustflame.2024.113606
IF: 4.4
2024-01-01
Combustion and Flame
Abstract:Fuel-air mixing strategy always plays an important role in NOx mitigation during ammonia/methane (NH3/CH4) co-combustion. In this paper, a novel dual-annular bluff-body burner is employed to investigate the effects of fuel/air distribution on the flame stability and NOx emission of NH3/CH4 flames. Both straight and swirl flames are studied over a wide range of four key operating parameters, i.e., the overall NH3 thermal ratio (E-NH3,E-ove), the NH3 thermal ratio (E-NH3,E-pri) and equivalence ratio (Phi(pri)) in the primary stream, and the swirl number (S-w) in the secondary stream. First, flame stability over these operating parameters is investigated, where E-NH3,E-ove shows nonmonotonic impacts on the lean and rich blowout limits represented by Phi(pri). Subsequently, an analysis of the Damk & ouml;hler number (Da) helps reveal the underlying mechanism. The reaction and flow time scales are adjusted while operating the distribution of CH4 and air in primary or secondary streams, thus altering the flame stability. Secondly, NOx emissions can be reduced by increasing E-NH3,E-pri and Phi(pri). A minimize value of similar to 400 ppm is obtained at relatively high Phi(pri) values (>1.4) for E-NH3,E-ove = 0.1 of both straight and swirl flames. Furthermore, OH*/NH2* chemiluminescence is measured to understand the kinetics of NOx formation. In straight flame, two NOx reduction mechanisms are revealed. While increasing operation parameters Phi(pri) and E-NH3,E-pri, OH inhibition mechanism is shown by lower OH* in the flame zone, and the NH2-induced reduction mechanism is marked by increasing NH2* content downstream. Subsequent chemical reactor network (CRN) analysis confirms that OH decrement and NH2 increment contribute to NO reduction. For swirl flames, both OH* and NH2* distribute in the flame zone and decrease with Phi(pri). When increasing Phi(pri), a continuous decrease of NOx emission indicates that the effect of NH2 on NOx reduction is suppressed compared to that of OH*. These findings suggest the feasibility of an enhanced fuel-nitrogen/hydrocarbon separation to further achieve effective NOx mitigation.