Abstract:Sulfur hexafluoride (SF6) gas is widely used in high-voltage circuit breakers, but due to its high global warming potential, substitutes are being sought. CO2 has been investigated as a candidate based on its arc interruption performance. The hot gas in the circuit breaker after current zero, with a complicated species composition caused by the dissociation and many other reactions, will lead to the electrical breakdown, which is one of the major concerns in assessing the arc interruption performance. Despite this, little research has been reported on the dielectric strength of hot CO2. In this paper, the dielectric properties of hot CO2 related to the dielectric recovery phase of the circuit breaker were investigated in the temperature range from 300 to 4000 K and in the pressure range from 0.01 to 1.0 MPa. Under the assumptions of local thermodynamic equilibrium (LTE) and local chemical equilibrium (LCE), the equilibrium compositions of hot CO2 were obtained based on Gibbs free energy minimization. The cross sections for interactions between electrons and the species are presented. The critical reduced electric field strength of CO2 was determined by balancing electron generation and loss. These were evaluated using the electron energy distribution function (EEDF) derived from the two-term Boltzmann transport equation. The result indicates that unlike SF6 or air, in hot CO2 the reduced critical electric field strength does not change monotonically with increasing heavy-particle temperature from 300 to 4000 K. CO2 has a superior dielectric strength to pure SF6 above 2500 K at 0.5 MPa, which means it has the potential to improve the interruption performance of the circuit breakers, while reducing the global warming effect. Good agreement was found with published experimental results and calculations for CO2 at room temperature, and with previous calculations for hot CO2.

Influence of Insulating Gas on Pressure Rise in Switch Cabinet Due to Internal Arc Fault

Study of the Arc Interruption Performance of SF6 Alternative Gases in Load Switch

Research on the Temperature Rise Characteristics of Medium‐Voltage Switchgear under Different Operation Conditions

Analysis of Pressure Rise in a Closed Container Due to Internal Arcing

Study of the Arc Interruption Performance of CO2 Gas in High-Voltage Circuit Breaker

Experimental Study of the Arc Plasma Characteristics in SF 6 , N 2 and CO 2 .

Study of the Arc Interruption Performance of SF 6 Alternative Gas in 35kV Circuit Breaker

Experiment Study on the Influence of Gas Humidity and Purity on the Property of 40.5 Kv N2 Insulated Switchgear

Experimental study on characteristics of co 2 and its gas mixtures with sf 6 for high voltage gas circuit breakers

Experimental Study on Arc Interruption Characteristics of SF6 and Its Mixtures With CF4

Effect of the Arc Extinguishing and Insulation Properties of C4F7N/CO2 Mixtures with Oxygen Addition: Experimental Investigations and Comparative Analysis

Simulation Analysis on the Impact of Different Filling Gases on the Temperature Rise of C-GIS

Experimental Studies on Insulation and Arc Extinguishing Performance of C5F10O/CO2 Gas Mixture

FLUORINATED NITRILE AS A POTENTIAL SUBSTITUTE OF SF6 FOR ARC INTERRUPTION IN SWITCHGEARS

The Development of SF6 Green Substitute Gas

Experimental Research on Flashover Characteristics of Insulator with N-2

Investigation on Critical Breakdown Electric Field of Hot Carbon Dioxide for Gas Circuit Breaker Applications

AC breakdown and decomposition products detection characteristics of eco-friendly insulating medium in gas insulated switchgear

Study on Breakdown Characteristics and Attenuation Characteristics of Air Mixed Gas

Analysis of Breaking Characteristics of C4F7N/CO2 Mixture Gas in Circuit Breaker

Chemical and Electron Interaction Properties of Potential Gaseous Insulation and Arc-quenching Media