Abstract:This paper reports an experimental investigation on the impact dynamics of liquid normal alkane (nheptane, n-decane and n-tetradecane) droplets on a stainless steel surface using high speed photography and long distance microscopic techniques. Particular interest is paid to comprehensively explore the effects of liquid viscosity and surface roughness on droplet spreading and bouncing dynamics at different thermal hydrodynamic impact regions. Specifically, firstly, high speed images identified four regimes (evaporation, nucleate boiling, transition boiling and film boiling regime) of physical phenomena that couple the droplet spreading hydrodynamics, heat transfer and phase change. Bubbles generation due to the heating of the surface with compression of air disk under the droplet was observed and this phenomenon is firstly promoted and then inhibited with the increase of the wall temperature until finally no bubbles were observed when wall temperature is beyond the Leidenfrost point (T-L). Rim disturbances during spreading were observed at relatively high Weber number with wall temperature higher than T-L. Increasing wall temperature reduces the rim disturbance. Secondly, the measured non-dimensional maximum spreading diameter beta(max) decreases with the increase of surface temperature until it becomes a constant when temperature is beyond T-L. Rough surface was found to have a lower T-L because of larger vapor pressure provided by more nucleation sites. Finally, for wall temperature beyond T-L, droplet bounces up after a certain period of residence time (tau(r)). It takes more time for droplet to rebound at larger We because of larger beta(max) takes longer time to retract and rebound. Both surface roughness and liquid viscosity showed no influence on time to reach beta(max) (tau(max)), but significantly increases tau(r) by slowing the retracting process, which both should be considered in future model of tau(r). (C) 2020 Elsevier Ltd. All rights reserved.

On the Role of Liquid Viscosity in Affecting Droplet Spreading on a Smooth Solid Surface

Dynamics of a Single Droplet with Different Viscosity Impact Onto a Stainless-Steel Surface

Experimental Study on the Droplet Impact on Solid Surface with Different Roughness

On Liquid Viscosity Effects on Droplet Splash and Receding Breakup on a Smooth Solid Surface at Atmospheric Pressure

Dynamics and Maximum Spreading of Droplet Impact on a Stationary Droplet on the Surface

Numerical Investigation of a Droplet Impacting Obliquely on a Horizontal Solid Surface

Droplet impact on rotating surfaces: The effect of centrifugal force and wettability on spreading dynamics

Impact and spread dynamics of a viscoelastic droplet on an inclined hydrophilic surface

Spreading and Bouncing of Liquid Alkane Droplets Upon Impacting on a Heated Surface

Spreading of Impinging Droplets on Nanostructured Superhydrophobic Surfaces

Reversed role of liquid viscosity on drop splash

Analytical Consideration of Liquid Droplet Impingement on Solid Surfaces

Effects of Surface Subcooling on the Spreading Dynamics of an Impact Water Droplet

Viscous Force Retards Initial Droplet Spreading

Numerical Study on Droplets Impacting Solid Spheres: Effect of Fluid Properties and Sphere Diameter

Analytical Consideration For The Maximum Spreading Factor Of Liquid Droplet Impact On A Smooth Solid Surface

Experimental Study on Droplet Splash and Receding Breakup on a Smooth Surface at Atmospheric Pressure

Impact of Viscous Droplets on Superamphiphobic Surfaces

Numerical investigation of droplet impact on a solid superhydrophobic surface

Dynamic behavior of droplet impacting on a moving surface

Spreading of a droplet impacting on a smooth flat surface: how liquid viscosity influences the maximum spreading time and spreading ratio