Abstract:Atomistic simulations were used to elucidate the mechanisms of localized plasticity and fracture in Si nanofibers embedded in Al matrix, with uniaxial tensile straining along the fiber axis. The Si nanofibers within the Al matrix exhibited large non-linear elastic strains followed by localized plasticity with the latter accounting for approximately 5% permanent length increase in the fibers. On the other hand, simulations with aligned Si nanofibers in vacuum (no Al matrix) exhibited elastic deformation only followed by cleavage fracture. Localized plasticity in Si nanofibers is accomplished by gliding of "zonal" partial dislocations with Burgers vector b=aSi3〈112〉 , which leads to synchronous shear of two shuffle-sets. Local stress concentration in Si nanofibers due to non-screw segments of dislocation loops around fibers triggers yielding in the nanofibers through the activation of dislocation sources at or near the interfaces but only below some critical fiber diameter, highlighting the role of nanoscale refinement in activating plasticity in embedded Si nanofibers in Al matrix. In addition, the kinetic barriers associated with the glide of edge/screw zonal dislocation in the perfect crystal and twinned crystal are computed using climbing-image nudge elastic band method. A higher mobility of the zonal dislocation in the twinned crystal suggests that twin boundaries can assist in dislocation glide parallel to the boundary. On the other hand, a nano-crack is nucleated at the interaction position of a glide partial dislocation with an intersecting growth twin boundary suggesting that intersecting twins serve to block glide and provide sites for crack nucleation.

Effect of Structural Anisotropy on the Dislocation Nucleation and Evolution in 6H SiC under Nanoindentation

Atomistic Investigations of Single-Crystal Silicon with Pre-Existing Defects

Amorphization and Dislocation Evolution Mechanisms of Single Crystalline 6H-SiC

Study of deformation mechanism of structural anisotropy in 4H–SiC film by nanoindentation

Anisotropic Deformation of 4H-Sic Wafers: Insights from Nanoindentation Tests

Lattice Bending, Disordering, and Amorphization Induced Plastic Deformation in a SiC Nanowire

Anisotropy in homogeneous dislocation nucleation by nanoindentation of single crystal Cu

Atomic-scale deformation behavior of SiC polytypes using molecular dynamics simulation

Mechanical Load-Induced Atomic-Scale Deformation Evolution and Mechanism of SiC Polytypes Using Molecular Dynamics Simulation

Atomic study on deformation behavior and anisotropy effect of 4C–SiC during nanoindentation

Surface deformation, phase transition and dislocation mechanisms of single crystalline 6H-SiC in oblique nano-cutting

New Mechanisms of Helical Dislocation Formation Via the Pinch-off Process Near a Nano-Inhomogeneity

High Strain Gradient Plasticity Associated with Wedge Indentation into Face-Centered Cubic Single Crystals: Geometrically Necessary Dislocation Densities

The Anisotropy of Deformation Behaviors in (100) and (010) Plane of Monoclinic 8-Ga2o3 Single Crystals

Doping-dependent Nucleation of Basal Plane Dislocations in 4H-Sic

The Anisotropy of Deformation Behaviors in (100) and (010) Plane of Monoclinic Β-Ga2o3 Single Crystals

Influence of Microstructures on Mechanical Behaviours of SiC Nanowires: a Molecular Dynamics Study

Effect of dislocation defects on the nano-scratching process of 4H–SiC

Indenter radius effect on mechanical response of a-(11–20), c-(0001), and m-(-1100) plane GaN single crystals in nanoindentation: A molecular dynamics study

Atomistic Simulations of Dislocation Activity in Si Nanofibers in Al-Si Eutectics

Effects of Crystalline Anisotropy and Indenter Size on Nanoindentation by Multiscale Simulation.