Abstract:Inhomogeneity in Li-ion cells leads to an underutilization of its energy and non-uniform degradation. In our previous work, the proof of concept was established for a setup with 4 tiny Varta cells connected in parallel, enabling to decouple the effect of the two parameters influencing inhomogeneous behavior. This is to mimic the thermal and potential gradients occurring in large-format commercial Li-ion cells. To represent the thermal gradient, the cells are placed at different temperature and is called T-dep setup; to represent the potential gradient, the cells have different shunt resistors connected in series to each of the tiny cells in the setup and is called V-dep setup. In this work, the above setup is used to perform long-term accelerated cycling tests (about 1100 cycles under 100 % Depth of Discharge, DOD) and their State of Health (SOH) is analyzed at periodic intervals. Two different degradation phenomena are primarily observed, namely reduction and oxidation of the solvent occurring at negative and positive electrodes, respectively. The solvent reduction results in a continuous growth of a passivation layer called Solid Electrolyte Interface (SEI). The coupled electrochemical model, from our previous work, is integrated to an aging model in this work. The model is parameterized using preliminary cycle aging data performed on individual pristine cells. The model captures the experimentally observed cell capacity fade trends, in both setups, quite well. A comparison of the cell interfacial resistance increase reveals that the model captures the experimental behavior quite well until about 400 cycles and underestimates after this point. Using this validated model, a comparison of capacity fade and impedance increase, of cells in setup and individually cycled cells, reveals that the setup conditions do not necessarily aggravate the inhomogeneous aging. Further analyses show that there is a reversal of cell utilization upon cycling, meaning degradation of less aged cells seems to accelerate compared to their more aged counterparts. Additional simulation analyses under narrow DOD cycling indicate that overall setup degradation rate increases but the inhomogeneity is not aggravated compared to individually cycled cells. All in all, V-dep setup aging results only in a reduced driving mileage while T-dep setup aging results in both reduced driving mileage and acceleration/deceleration capability.

Impedance Characterization of Lithium-Ion Batteries Aging under High-Temperature Cycling: Importance of Electrolyte-Phase Diffusion

Simulation Study on Heat Generation Characteristics of Lithium-Ion Battery Aging Process

Experimental Study on High-Temperature Cycling Aging of Large-Capacity Lithium Iron Phosphate Batteries

Insights into the Swelling Force in Commercial LiFePO4 Prismatic Cell

Experimental investigation of the lithium-ion battery impedance characteristic at various conditions and aging states and its influence on the application

An Electrochemistry-Based Impedance Model for Lithium-Ion Batteries

Electrochemical and Thermal Features of Aging Lithium-Ion Batteries Cycled at Various Current Rates

Aging diagnosis-oriented three-scale impedance model of lithium-ion battery inspired by and reflecting morphological evolution

Temperature-driven path dependence in Li-ion battery cyclic aging

Application of Electrochemical Impedance Spectroscopy to Degradation and Aging Research of Lithium-Ion Batteries

Unravelling and Quantifying the Aging Processes of Commercial Li(Ni0.5Co0.2Mn0.3)O2/Graphite Lithium-ion Battery under Constant Current Cycling

Impact of aging on the thermophysical properties of lithium-ion battery electrodes

Thermal characteristic evolution of lithium−ion batteries during the whole lifecycle

Study of Early Cycling Deterioration of a Ni/MH Battery by Electrochemical Impedance Spectroscopy

Analysis of Performance Degradation in Lithium-Ion Batteries Based on a Lumped Particle Diffusion Model

Design and Validation of Lifetime Prediction Model for Lithium-Thiocarbonyl Chloride Batteries Based on Accelerated Aging Experiments

Capacity Degradation and Aging Mechanisms Evolution of Lithium-Ion Batteries under Different Operation Conditions

Dynamic cycling enhances battery lifetime

Investigation on Topographic, Electrochemical and Thermal Features of Aging Lithium-Ion Cells Induced by Overcharge/over-Discharge Cycling

Aging Characterization of Lithium Iron Phosphate Batteries Considering Temperature and Direct Current Undulations as Degrading Factors

Modeling the internal inhomogeneous aging behavior within individual Li-ion cells – During cycle aging