Abstract:Objective On-chip gas sensor based on infrared absorption spectroscopy is useful for environmental detection because of its small size and low power consumption. Direct absorption spectroscopy is a commonly used detection technique for onchip gas sensors, but the noise of this detection method is high. The wavelength modulation spectroscopy technique can suppress noise. The combination of the wavelength modulation spectroscopy technique with the on-chip gas sensor can improve the performance of the sensor. However, the waveguide parameters including external confinement factor, loss, and length influence the second harmonic signal. A slot waveguide can increase the external confinement factor by using the mode field distributed in the slot for sensing. We provide guidance for the design of on-chip gas sensors based on wavelength modulation spectroscopy. Methods The optical field distribution results and external confinement factor are obtained by COMSOL Multiphysics with electromagnetic waves and frequency domain module. The optical parameters of the waveguide are set at the wavelength of 3291 nm. The chalcogenide rectangular waveguide is fabricated by the lift-off method. The process of the lift-off method includes spinning photoresist, lithography, development, thermal evaporation, and removal of photoresist. The noise of the waveguide sensing system is used for simulation analysis. The second harmonic signal amplitude of the on-chip gas sensor is simulated by MATLAB. The important parameters of the simulation model include gas absorption parameters at 3291 nm, waveguide parameters, and laser parameters. The simulated limit of detection is calculated based on the signal-to-noise ratio. Results and Discussions The trapezoid waveguide morphology is shown in Fig. 2, and the external confinement factor of the waveguide is about 8%. The CH4 sensing results based on wavelength modulation spectroscopy at 3291 nm show that the response result is linear (Fig. 5). The slot waveguide structure with magnesium fluoride as the lower cladding layer and chalcogenide glass as the core layer is optimized, and the external confinement factor reaches 42% (Fig. 6). Based on the experimental results, the effects of waveguide loss and waveguide length on the second harmonic signal amplitude are studied (Fig. 7). Decreasing waveguide loss and selecting an appropriate waveguide length can increase the sensing performance. The influence of the change of environmental pressure on the slot waveguide sensor can be ignored (Fig. 8). The influence of fabrication errors on slot waveguide sensor performance is analyzed (Fig. 9). Conclusions In this paper, an optical waveguide CH4 sensor with a lower cladding of magnesium fluoride and a core layer of chalcogenide glass is fabricated. With the combination of wavelength modulation spectroscopy technique and on-chip optical waveguide gas sensor, the CH4 sensing performance is analyzed. The performance of the slot waveguide CH4 sensor combined with the wavelength modulation spectroscopy technique is studied. Decreasing waveguide loss and choosing an appropriate waveguide length can increase the amplitude of the second harmonic signal and improve the performance of the waveguide gas sensor. When the waveguide loss is < 3 dB/cm, the limit of detection can be <1x 10(-3). Further reducing the noise of the system can also reduce the limit of detection. The influence of the change of environmental pressure on the slot waveguide sensor can be ignored. The influence of fabrication errors on slot waveguide sensor performance is analyzed. We provide guidance for the design of an on- chip gas sensor based on wavelength modulation spectroscopy.

A Slot Microring Sensor with Feedback Spiral Waveguide for Trace Gas CH4 Sensing in Mid-Infrared Region

Monolithic Mid-IR Methane Gas Sensor with Waveguide-Integrated Detector

Ultra-high-power-confinement-factor Integrated Mid-Infrared Gas Sensor Based on the Suspended Slot Chalcogenide Glass Waveguide

Theoretical Study of Microcavity-Enhanced Absorption Spectroscopy for Mid-Infrared Methane Detection Using a Chalcogenide/silica-on-fluoride Horizontal Slot-Waveguide Racetrack Resonator.

A Single Slot Micro-Ring Structure for Simultaneous CO2 and CH4 Gas Sensing

Design of a Mid-Infrared Suspended Chalcogenide/silica-on-silicon Slot-Waveguide Spectroscopic Gas Sensor with Enhanced Light-Gas Interaction Effect

On-chip Long-Wave Infrared Gas Sensor Based on Subwavelength Grating Waveguide

Mid-infrared Chalcogenide Suspended Slot Waveguide for Gas Sensing

On-chip mid-infrared silicon-on-insulator waveguide methane sensor using two measurement schemes at 3.291 m

Theoretical and Experimental Investigation of On-Chip Mid-Infrared Chalcogenide Waveguide Ch4 Sensor Based on Wavelength Modulation Spectroscopy

On-chip mid-infrared silicon-on-insulator waveguide methane sensor using two measurement schemes at 3.291 μm

An Ag-assisted Silicon Slot Waveguide Sensor Model for Mid-Infrared Spectra Gas Detection with Micro-Ring Air Pressure Compensation

On-Chip Mid-Infrared Wavelength Modulation Spectroscopy Gas Sensing Technique

Development Of A Mid-Infrared Interband Cascade Laser Methane Sensor

Performance Improvement of On-Chip Mid-Infrared Waveguide Methane Sensor Using Wavelet Denoising and Savitzky-Golay Filtering

Silicon Waveguide Sensors for Carbon Dioxide Gas Sensing in the Mid-Infrared Region

Mid-infrared chalcogenide slot waveguide plasmonic resonator sensor embedded with Au nanorods for surface-enhanced infrared absorption spectroscopy

Ultra-high-enhancement-factor integrated long-wave infrared gas sensor based on the tapered sub-wavelength grating slot waveguide

A High-Sensitivity D-Shaped Microgroove Photonic Crystal Fiber Gas Sensor Based on Surface Plasmon Resonance

A Ndir Mid-Infrared Methane Sensor With A Compact Pentahedron Gas-Cell

Double-slot micro-ring resonators with trapezoidal subwavelength grating as ultra-sensitive biochemical sensors