Abstract:In low-strength ammonium wastewater (LSAWW) treatment, the application of anammox-based process is still limited due to extreme instability and the poor nitrogen removal rate (NRR). In this work, granule sludge, comprised of functional microbes and hydroxyapatite (HAP), was inoculated and cultivated in a one-stage partial nitritation/anammox (PNA) reactor for LSAWW treatment. The results showed that at the hydraulic retention time (HRT) of about 1.0 h and the influent ammonium concentration of 63.0 mg/L, an average NRR of 1.28 kg/m3/d was achieved, which far exceeds that reported in similar studies. The main inorganic matter in sludge was identified as HAP through the X-ray diffractometer and Raman spectrum analysis. The tomographic images of wet granule created through computed tomography revealed that the interior density of the granules was uneven and many hollow structures existed in the granule interior. Combined with the Scanning Electron Microscope images of dry granules, it was found that the granules were comprised of hollow sub-granules. Since the biomass in the reactor increased with no obvious increase in the granule size, it was inferred that the hollow sub-granules had fragile connections with each other and that granules division occurred easily, resulting in the high dispersity of sludge. Florescence in situ hybridization results also showed that the ammonium-oxidizing bacteria and anammox bacteria were mainly distributed in the two sides of the sub-granule shells and the HAP in the middle. This kind of structure raised the density of granules and improved the settleability of sludge, which made it possible to achieve a high biomass in the reactor at a short HRT. Therefore, the sludge formed in the reactor was concentrated, highly dispersive and easily settleable. These factors appear to be crucial for achieving the desired nitrogen removal performance. This study marks a big leap in LSAWW treatment through the one-stage PNA process and has great potential in actual applications.

Development of a Hybrid Partial-Nitrification and Anammox Reactor with Stirrer

Study on Sludge Characteristics and Nitrogen Removal Mechanism of Hybrid Partial Nitrification Anammox Reactor (HPNA)

Enhanced Nitrogen Removal by Partial Nitrification-Anammox Process with a Novel High-Frequency Micro-Aeration (HFMA) Mode: Metabolic Interactions among Functional Bacteria

Enrichment of High Activity Nitrifers to Enhance Partial Nitrification Process.

Partial nitritation and anaerobic ammonium oxidation in biofilter reactors treating low ammonium strength wastewater

Partial Nitrification in an Air-Lift Reactor with Long-Term Feeding of Increasing Ammonium Concentrations

Nitrogen Removal and Bacterial Mechanism in a Hybrid Anoxic/oxic Baffled Reactor Affected by Shortening HRT in Treating Manure-Free Piggery Wastewater

Effective Partial Nitrification of Ammonia in a Fluidized Bed Bioreactor.

Evaluation of the Combined C/N ratio, DO Set Point, and HRT Influence on Nitrogen Removal Rate in One-Stage Reactor Through Partial Nitrification Anammox Process During Treatment of Synthetic Digestate of Poultry Litter Wastewater

Start-up of a Three-stage PN/A Granular Sludge Reactor for Treating Wastewater with High Concentrations of Ammonia

Practicing Anammox in a Novel Hybrid Anaerobic-Aerobic Baffled Reactor for Treating High-Strength Ammonium Piggery Wastewater with Low COD/TN Ratio.

Synergy of Partial-Denitrification and Anammox in Continuously Fed Upflow Sludge Blanket Reactor for Simultaneous Nitrate and Ammonia Removal at Room Temperature.

Partial nitrification of digested sludge liquor with Low C/N and high-concentration ammonia

Enhanced Nitrogen Removal from Domestic Wastewater by Partial-Denitrification/Anammox in an Anoxic/Oxic Biofilm Reactor

A/O Hybrid Membrane Bioreactor for High-Loaded Ammonia Wastewater Treatment

High-rate Partial Nitrification Treatment of Reject Water As a Pretreatment for Anaerobic Ammonium Oxidation (Anammox)

Enhanced Microbial Metabolism in One Stage Partial Nitritation-Anammox System Treating Low Strength Wastewater by Novel Composite Carrier.

Achieving superior nitrogen removal performance in low-strength ammonium wastewater treatment by cultivating concentrated, highly dispersive, and easily settleable granule sludge in a one-stage partial nitritation/anammox-HAP reactor

A novel two-stage partial-nitritation/anammox (PN/A) process based on zeolite biological fixed bed reactor for low-strength ammonium wastewater treatment

Performance of Partial Nitritation - Microfiltration-Anammox (PN-MF-A) Process with Enhanced System Stability Via In-Between Membrane Filtration for Sludge Anaerobic Reject Water Treatment

Enhanced Nitrogen Removal from Municipal Wastewater Via a Novel Combined Process Driven by Partial Nitrification/anammox (PN/A) and Partial Denitrification/anammox (PD/A) with an Ultra-Low Hydraulic Retention Time (HRT).