Abstract:This paper proposes a sensorless control strategy using sine-wave high-frequency (HF) voltage injection for interior permanent magnet synchronous motors (IPMSMs) fed by a three-phase four-switch (TPFS) inverter, with a single current sensor. Three-phase currents are reconstructed by a single current sensor with modification of the inverter topology. The principle of the phase current reconstruction strategy in TPFS inverter is analyzed and the topology of the proposed drive system is illustrated. Then, the normal areas and the dead zones for current reconstruction are investigated in detail, and the vector synthesis method is also explained. Furthermore, the zero vector synthesis strategy and the pulse width modulation (PWM) generation method are also presented, where two current sampling points are applied in each PWM cycle for phase current reconstruction. Finally, an HF voltage injection based sensorless control strategy in the proposed drive system is realized by voltage projection on the proposed k-l axis coordinate system. The reconstructed phase currents track the actual ones accurately, and the estimation error of the rotor position by using the reconstructed phase currents is within +/- 0.1 rad. The effectiveness of the proposed scheme is verified by simulation and experimental results on a 5-kW IPMSM prototype.

FPGA Based Hybrid Sensorless Controller Design for PMSM Drive System

Deadbeat Current Predictive Control for PMSM Drives Based on a Single FPGA with Digital Implementation Optimization

An Accurate Discrete Current Controller for High-Speed PMSMs/Gs in Flywheel Applications

Current Controller Design in Discrete-Time Domain for Pmsm/G in Flywheel Energy Storage Systems

Speed Sensorless Nonlinear Control Of Pmsm Drives

FPGA Implementation of an Arbitrary Injection based Sensorless Control for PMSM

FPGA-based sensorless control for PMSM drives using the stator/rotor frame extended Kalman filter

FPGA Implementation of Predictive Cascaded Speed and Current Control of PMSM Drives with Two-Time-Scale Optimization

High-Frequency Voltage Injection Sensorless Control Technique for IPMSMs Fed by a Three-Phase Four-Switch Inverter with a Single Current Sensor

FPGA-based sensorless PMSM drive using parallel reduced-order Extended Kalman Filter

A High-efficiency PMSM Sensorless Control Approach Based on MPC Controller

FPGA Implementation of Sensorless Sliding Mode Observer with a Novel Rotation Direction Detection for PMSM Drives

FPGA-based Real-Time Simulation of Five-Phase PMSM for the HIL Applications

A Novel Deadbeat Control with Extended State Observer for PMSM Sensorless Drive System

Current Sampling Scheme for Finite-Control-Set Model Predictive Control of PMSM Drives with Two Shunt Resistors

Position Estimation Accuracy Improvement for SPMSM Sensorless Drives by Adaptive Complex-Coefficient Filter and DPLL

Enhanced Sensorless Control of SPMSM Based on Stationary Reference Frame High-Frequency Pulsating Signal Injection

A Time-Delay Compensation Method For Pmsm Sensorless Control System Under Low Switching Frequency

Nonlinear Speed Sensorless Control Of Pmsm Drives

A Robust Encoderless Control for PMSM Drives: a Revised Hybrid Active Flux Based Technique

Research on Position-free HIL Control of high speed permanent magnet synchronous Motor based on FPGA