Abstract:In this work, the wastewater obtained from the hydrothermal liquefaction of black liquor was treated and valorized for hydrogen production by supercritical water gasification (SCWG). The influence of the main process parameters on the conversion yield was studied. The experiments were conducted at three different temperatures (below and above the critical point of water): 350 °C, 450 °C and 600 °C. The results showed that by increasing the temperature from 350 °C to 600 °C, the total gas yield was highly improved (from 1.9 mol gas/kg of dried feedstock to 13.1 mol gas/kg of dried feedstock). The H2 composition was higher than that of CH4 and CO2 at 600 °C, and the HHV of the obtained gas was 61.2 MJ/kg. The total organic carbon (TOC) removal efficiency was also improved by increasing the temperature, indicating that the SCWG process could be used for both applications: (i) for wastewater treatment; (ii) for producing a high calorific gas. The experiments with the Raney-nickel catalyst were performed in order to study the catalyst's influence on the conversion yield. The results indicated that the catalyst enhances carbon conversion and gas production from mild to higher temperatures. The maximum total gas yield obtained with this catalyst was 32.4 mol gas/kg of dried feedstock at 600 °C, which is 2.5 times higher than that obtained at the same operating conditions without a catalyst. The H2 yield and the HHV of the obtained gas with the catalyst were 20.98 mol gas/kg dried feedstock and 80.2 MJ/kg, respectively. However, the major contribution of the catalytic SCWG process was the improvement of the total gas yield at mild operating temperatures (450 °C), and the obtained performance was even higher than that obtained at 600 °C without catalyst (17.81 mol gas/kg dried feedstock and 13.1 mol gas/kg dried feedstock, respectively). This is a sustainable approach for treating wastewater at mild temperatures by catalytic SCWG.

Gasification of Landfill Leachate in Supercritical Water: Effects on Hydrogen Yield and Tar Formation

Co-gasification of Acid Hydrolysis Residues and Sewage Sludge in a Downdraft Fixed Gasifier with CaO As an In-Bed Additive

Effect of CaO on Conversion of Lignite to Hydrogen-Rich Gas in Supercritical Water

STUDY ON CO-GASIFICATION OF SLUDGE AND COAL IN SUPERCRITICAL WATER

Supercritical water oxidation treatment of landfill leachate membrane filtered concentrate

Clean treatment and resource utilization of oilfield wastewater using supercritical water gasification

Hydrogen Production by Catalytic Supercritical Water Gasification of Black Liquor-Based Wastewater

Effects of Lewis acid on catalyzing gasification of sewage sludge and model compounds in supercritical water

Conversion of kitchen waste effluent to H2-rich syngas via supercritical water gasification: Parameters, process optimization and Ni/Cu steam reforming reaction. Moreover

Effects of Process Parameters on Sulfur Migration and H2S Generation during Supercritical Water Gasification of Sludge

Treatment of landfill leachate by SCWO process

Valorization of Sewage Sludge Through Catalytic Sub- and Supercritical Water Gasification

Insight into the interconversion mechanisms during the supercritical water gasification of bark

Assessment of Sewage Sludge Gasification in Supercritical Water for H-2-rich Syngas Production

Experimental investigation on the supercritical water gasification of coal by integrating the hydrogen oxidation process into a supercritical water fluidized bed

Sewage sludge treatment via hydrothermal carbonization combined with supercritical water gasification: Fuel production and pollution degradation

Steam Gasification of Land, Coastal Zone and Marine Biomass by Thermal Gravimetric Analyzer and a Free-Fall Tubular Gasifier: Biochars Reactivity and Hydrogen-Rich Syngas Production.

Experimental Study on Air/steam Gasification of Leather Scraps Using U-type Catalytic Gasification for Producing Hydrogen-Enriched Syngas

Comprehensive experimental study on supercritical water gasification of oilfield sludge: Effect of operation parameters, and catalysts on the products

Thermodynamic Study on the Integrated Supercritical Water Gasification with Reforming Process for Hydrogen Production: Effects of Operating Parameters

Gasification of effluent from food waste treatment process in sub- and supercritical water: H<sub>2</sub>-rich syngas production and pollutants management