Abstract:Al deoxidation equilibria in liquid iron over the whole composition range from very low Al ([pct Al] = 0.0027) to almost pure liquid Al were thermodynamically modeled for the first time using the Modified Quasichemical Model in the pair approximation for the liquid phase. The present modeling is distinguished from previous approaches in many ways. First, very strong attractions between metallic components, Fe and Al, and non-metallic component, O, were taken into account explicitly in terms of Short-Range Ordering. Second, the present thermodynamic modeling does not distinguish solvent and solutes among metallic components, and the model calculation can be applied from pure liquid Fe to pure liquid Al. Therefore, this approach is thermodynamically self-consistent, contrary to the previous approaches using interaction parameter formalism. Third, the present thermodynamic modeling describes an integral Gibbs energy of the liquid alloy in the framework of CALPHAD; therefore, it can be further used to develop a multicomponent thermodynamic database for liquid steel. Fourth, only a small temperature-independent parameter for ternary liquid was enough to account for the Al deoxidation over wide concentration (0.0027 < [pct Al] < 100) and wide temperature range [1823 K to 2139 K (1550 °C to 1866 °C)]. Gibbs energies of Fe-O and Al-O binary liquid solutions at metal-rich region (up to oxide saturation) were modeled, and relevant model parameters were optimized. By merging these Gibbs energy descriptions with that of Fe-Al binary liquid modeled by the same modeling approach, the Gibbs energy of ternary Fe-Al-O solution at metal-rich region was obtained along with one small ternary parameter. It was shown that the present model successfully reproduced all available experimental data for the Al deoxidation equilibria. Limit of previously used interaction parameter formalism at high Al concentration is discussed.

Heterogeneous Nucleation Behavior in Al Deoxidized Liquid Iron

Quantitative Relationship Between The Nucleation Undercooling Of Liquid Iron And Its Liquid Structure: Investigated By In Situ Synchrotron Radiation

Atomic Distance Tuning Effect for Nucleation in Liquid Iron

The Nucleation Potency of in Situ-Formed Oxides in Liquid Iron

Oxidation Mechanism of Three Fe-Al Alloys with and Without Addition of 0.1 At% Yttrium at 800 °C

Solidification Microstructure Evolution and Grain Refinement Mechanism under High Undercooling of Undercooled Ni90Cu10 Alloys

Observation on the Oxidation of Liquid Al by Environmental Transmission Electron Microscope

Growth Velocity-Undercooling Relationship and Structure Refinement Mechanism of Undercooled Ni-Cu Alloys

Thermodynamic insight into the growth of nanoscale inclusion of Al-deoxidation in Fe–O–Al melt

Effect of Minor Addition of Co on Nonequilibrium Solidification of Deeply Undercooled Cu Based Alloys

Solidification Structure Of Undercooled Alloys

The Local Structure of Molten Ni 1−x Al X : an Ab Initio Molecular Dynamics Study

Connecting short-range order for the liquid-solid transition of Al-Cu-Fe alloys

Composition- and Temperature-Dependent Liquid Structures in Al–Cu Alloys: Anab Initiomolecular Dynamics and X-Ray Diffraction Study

Unravelling the evolution of oxides at the aluminum liquid/vapor interface

Atomic Ordering at the Liquid-Al/MgAl2O4 Interfaces from Ab Initio Molecular Dynamics Simulations

Molecular Dynamics Simulation of Homogeneous Nucleation and Growth of Supercooled Al Liquid

Aluminum Deoxidation Equilibria in Liquid Iron: Part II. Thermodynamic Modeling

Aluminum Deoxidation Equilibria in Liquid Iron: Part III—Experiments and Thermodynamic Modeling of the Fe-Mn-Al-O System

Atomic Structural Competition in the Al 85.5 Ni 9.5 La 5 Alloy During Liquid-to-Solid Transition

Intermetallics in Ni–Al Binary Alloys: Liquid Structural Origin