Abstract:In this paper, the nonlinear resonance characteristics of a dual-rotor system are investigated with the consideration of a local defect on the inter-shaft bearing of the system. A simplified model of the dual-rotor system is proposed by considering that there is a local defect on the inner ring of inter-shaft bearing. The local defect is modelled as an inverted isosceles trapezoidal groove, which can make great influence on the inter-shaft bearing force due to the change of radial clearance of the inter-shaft bearing. The motion equations of the dual-rotor system are formulated by using the Lagrange equation. The Runge-Kutta method is employed to solve the motion equation. The amplitude-frequency response curve of the dual-rotor system is obtained, the abnormal resonance characteristics are analyzed. In addition, the influence of defect parameters, rotors and support parameters and inter-shaft bearing parameters on the amplitude-frequency characteristics of the system are discussed. The results show that there are two main resonance peaks and four abnormal resonance peaks on the amplitude-frequency response curve of the dual-rotor with a local defect on the inner ring of the inter-shaft bearing. Through analyzing the vibration response of the abnormal resonance peaks, it is found that the first two abnormal resonances are caused by the combined resonance, which are related to the inner ring fault and the rotational speed of high or low pressure rotors, and the last two resonances are caused by the induced resonance of the inner ring fault. At the same time, when the parameters of defect, rotors and support and inter-shaft bearing change, the resonance of the system also shows the corresponding change law.

The Rotor Speed Choice of Signal Acquisition in a Ball Bearing-rotor System with a Raceway Local Defect Based on Dynamic Analysis

Bearing Fault Diagnosis under Non-Stationary Conditions Based on a Speed Signal Resonance Component Demodulation Algorithm

Dynamic Behavior Analysis of a Rotor-Bearing-Squeeze Film Damper Coupling System with Bearing Outer Race Localized Defect

Bearing Fault Diagnosis under Time-Varying Speed and Load Conditions Via Speed Sensorless Algorithm and Angular Resample

Model for dynamic characteristics produced by inner race local defect in ball bearing system and its simulation

Nonlinear vibration signatures for localized fault of rolling element bearing in rotor-bearing-casing system

Simulation and Experimental Analysis of Rolling Element Bearing Fault in Rotor-Bearing-casing System

Dynamics Analysis Control on Dual Delay Bearing-Rotor System

Simulation and feature extraction of inter-shaft bearing fault in rotor-bearing-casing system

Dynamic modeling and vibration analysis for the gear-rotor-bearing system with localized failures

Vibration Signal Modeling of a Localized Defective Rolling Bearing under Unbalanced Force Excitations

Response Analysis Of A Linear Rotor-Bearing System Under Combined Non-Stationary Seismic And Harmonic Excitations

Unknown bearing fault diagnosis under time-varying speed conditions and strong noise background

Dynamic characteristics of ball bearing-coupling-rotor system with angular misalignment fault

An investigation of dynamic characteristics in rotor-bearing system with combined bearing and coupling defects

Experimental Verification and Nonlinear Dynamic Response Analysis of a Rolling Element Bearing with Localized Defects

Fault Detection in Rotor-Bearing System Using Measured Vibration Data

Bearing Race Fault Detection Using an Optomechanical Micro-Resonator

Study on the Dynamic Response of an Unbalanced Rotor System Supported by Ball Bearings

Nonlinear resonance characteristics of a dual-rotor system with a local defect on the inner ring of the inter-shaft bearing

Motor Bearing Fault Diagnosis in an Industrial Robot Under Complex Variable Speed Conditions