Abstract:It is common to find that some of the lactose in dairy powders and pharmaceutical tablets is present in the unstable amorphous state. Therefore, their crystallization thermodynamics in different solvents are particularly important. In this paper, the solubility of α-lactose monohydrate (α-LM) in 15 mono-solvents such as ethanol, isopropanol, methanol, 1-propanol, 1-butanol, 2-butanol, isobutanol, 1-pentanol, isoamylol, 1-hexanol, 1-heptanol, 1-octanol, propanoic acid, acetonitrile, and cyclohexanone was evaluated by using the gravimetric method in the temperature ranges from 274.05 K to 323.05 K at constant pressure (1 atm). In the given temperature range, the solubility of α-LM in these solvents increased with the rising of temperature, the highest solubility of α-LM was found in methanol (2.37 × 104), and the lowest was found in 1-hexanol (0.80 × 105). In addition, the increase of α-LM solubility in isopropanol was the largest. The sequence at 298.15 K was: methanol > 1-butanol > isopropanol > ethanol > 1-propanol > 1-heptanol > isobutanol > propionic acid > 1-pentanol > 1-octanol > acetonitrile > isoamylol > 2-butanol > cyclohexanone > 1-hexanol. Solvent effect analysis shows that the properties of α-LM are more important than those of solvents. The Apelblat equation, λh equation, Wilson model, and NRTL model were used to correlate the experimental values. The root-mean-square deviation (RMSD) and relative average deviation (RAD) of all models were less than 2.68 × 10−2 and 1.41 × 10−6, respectively, implying that the fitted values of four thermodynamic models all agreed well with the experimental values. Moreover, the thermodynamic properties of the dissolution process (i.e., dissolution Gibbs free energy (ΔdisG), molar enthalpy (ΔdisH), and molar entropy (ΔdisS)) for α-LM in selected solvents were determined. The results indicate that ΔdisH/(J/mol) (from 0.2551 to 6.0575) and ΔdisS/(J/mol/K) (from 0.0010 to 0.0207) of α-LM in these solvents are all positive, and the values of ΔdisH and ΔdisS. ΔdisG/(J/mol) (from −0.0184 to −0.6380) are all negative. The values were observed to decrease with rising temperatures, implying that α-LM dissolution is an endothermic, entropy-driven, and spontaneous process. The solid–liquid equilibrium data and dissolution thermodynamics of α-LM were obtained, which provide a basis for industrial production.

Solid-Liquid Equilibrium Of L-Alanyl-L-Glutamine Form Ii In Methanol Plus Water And Isopropanol Plus Water Systems

Solubility measurement, thermodynamic modeling, and molecular dynamic simulation of glycylglycine in five binary solvents

Determination of L -Glutamine Solubility in 12 Pure Solvent Systems from 283.15 to 323.15 K

Solubility and Solvent Effect Analysis of Boc- l -glutamine in Different Solvents at Multiple Temperatures

Solid–Liquid Equilibrium of GLA-NaCl System and Its Application for Separating GLA and NaCl

Crystallization Thermodynamics of Α-Lactose Monohydrate in Different Solvents

Solubility Behavior of l -Arginine α-Ketoglutarate in Ten Pure and Two Binary Water + Ethanol and Water + Acetone Solvent Systems

Solubility Behavior and Synergistic Solvation Effects of N -Benzylglycine in Eleven Neat and One Binary Solvent Systems from 283.15 to 323.15 K

Volumetric properties of amino acids in aqueous xylitol solutions

Solubility Behavior and Polymorphism of L-Arginine L-Pyroglutamate in Nine Pure Solvents and a Binary Water plus Ethanol System

Solubility and Thermodynamics of D-Glucosamine 2-Sulfate Sodium Salt in Water and Binary Solvent Mixtures with Methanol, Ethanol and N-Propanol

A study on the solubility of some amino acids in (H 2 O + EtOH) and (H 2 O + EtOH + NaI) systems by gravimetric method at T = 298.15 K: Experimental measurements and COSMO-RS calculations

Solubility Measurement and Model Correlation of N,N′-Oxalyldiglycine in Eleven Pure Solvents and a Binary Solvent from 293.15 to 333.15 K

Research on Solubility and Bio-Solubility of Amino Acids Ionic Liquids

Study on Vapor-Liquid Equilibrium and Microscopic Properties of Glycine + H2O, L-Histidine + H2O, and L-Tryptophan + H2O

Solubility of ʟ-Arginine in Twelve Mono-Solvents: Solvent Effects, Molecular Simulations and Model Correlations

Thermodynamic Modeling, Hansen Solubility Parameters, and Solubility Behavior of <i>N</i>-Benzyloxycarbonyl-L-asparagine in Twelve Pure Solvent Systems at 283.15-323.15 K

Binary Solid–Liquid Solubility Determination and Model Correlation of Quizalofop-p-ethyl in Different Pure Solvents

Solubility Determination and Thermodynamic Modeling of N -Acetylglycine in Different Solvent Systems

Study on Vapor–Liquid Equilibrium and Microscopic Properties of Glycine + H 2 O, l -Histidine + H 2 O, and l -Tryptophan + H 2 O

Volumetric Properties of Amino Acids in 2-Chloroethanol-water Mixed Solvents