Abstract:Lignin is a potential resources of aromatic compound that can be obtained from renewable biomass. There are many ongoing research efforts to utilize lignin as a sustainable alternative to petroleum derived aromatic compounds. Because of the complex three-dimensional structure, the depolymerization of lignin into monomer molecule became a core challenge for the utilization of lignin. The beta-O-4 structure is the most abundant linkage in lignin. Owing to its abundance, the beta-O-4 structure has been representatively studied in many aspects of scientific research on lignin degradation. Among the different reported strategies for the cleavage of beta-O-4 ether bonds, C-C bond cleavage is one of the most important approaches to depolymerizing lignin. In this study, we accomplished the oxidative C-C bond cleavage of the beta-O-4 structure by the catalysis of NH4VO3 using the pre-oxidized 2-phenoxy-1-phenylethanone (1a) as a model compound of lignin. In the DMSO-HOAc solvent system, benzoic acid and phenol were produced in a moderate condition, the yeild of benzoic acid and phenol were 82.1% and 88.1%, respectively. The reaction process was investigated via H-1 NMR and X-ray photoelectron spectra (XPS) characterizations and the possible reaction pathway was further proposed. As the results shown, two possible reaction routes existed in this catalytic system. Pathway one: the 2-hydroxyacetophenone and phenol formed after the C-O bond cleavage of 1a in the acidic system, then, the intermediate 2-hydroxyacetophenone was converted to benzoic via the cleavage of C-C bond. Pathway two: benzoic acid and phenol yielded by the C-C bond of 1a cleaved directly over the catalyst. In addition, the catalyst characterization results confirmed that the oxovanadium(V) directly catalyzed the depolymerization of the beta-O-4 structure and generated oxovanadium(IV), then oxovanadium(IV) was oxidized by O-2 and finish the catalytic cycle. All reactions were carried out by the following general procedure. This reaction was carried out in glass tube and heated by oil bath. 0.5 mmol of 1a was added into 2 mL of DMSO-HOAc (V: V= 3: 1) with 30 mol% NH4VO3 (17.5 mg) under an oxygen atmosphere (101 kPa, in balloon). The reactor was heated to 100 degrees C with a powerful stirring. After 8 h, the reaction was cooled to room temperature, then 5 mL of ethyl acetate was added into the mixtures. Ash black precipitate was removed by filtration and the liquid mixture was detected by GC.

Oxidative Depolymerization of Cellulolytic Enzyme Lignin over Silicotungvanadium Polyoxometalates

Catalytic Depolymerization of Lignin over Cesium Exchanged and Transition-Metal Substituted Heterogeneous Polyoxometalates.

Efficient Lignin Depolymerization Process for Phenolic Products with Lignin-Based Catalysts and Mixed Solvents

Depolymerization of Lignin by Catalytic Oxidation with Aqueous Polyoxometalates

Catalytic Oxidative Depolymerization of Lignin to Aromatic Compounds Using Transition Metal Doped Ionic Liquid-Based Polyoxometalate Catalysts

Complementing Vanillin and Cellulose Production by Oxidation of Lignocellulose with Stirring Control

Production of vanillin via oxidation depolymerization of lignin over Fe- and Mn-modified TS-1 zeolites

Depolymerization of Organosolv Lignin over Silica-alumina Catalysts

Catalytic Depolymerization of Enzymatic Hydrolysis Lignin into Monomers over an Unsupported Nickel Catalyst in Supercritical Ethanol

Oxidative Lignin Depolymerization Using Metal Supported Hydrotalcite Catalysts: Effects of Process Parameters on Phenolic Compounds Distribution

High-Efficiency Catalytic Hydrodeoxygenation of Lignin-Derived Vanillin with Nickel-Supported Metal Phosphate Catalysts

Heterogeneous Catalytic Oxidation for Lignin Valorization into Aromatic Compounds over Acid-Redox Bifunctional Polyoxometalates

Fabrication and application of amphiphilic polyoxometalate catalyst (CTA)nH5-nPMo10V2O40 for transformation of lignin into aromatic chemicals

Role of Cu–Mg–Al Mixed Oxide Catalysts in Lignin Depolymerization in Supercritical Ethanol

A combined experimental and theoretical study on vanadium-catalytic oxidation of lignin to produce carboxylic acids

Mechanism Studies in Electrochemical Depolymerization Processes of Alkali and Organosolv Lignin

Depolymerization of Lignin to Aromatics by Selectively Oxidizing Cleavage of C–C and C–O Bonds Using CuCl2/Polybenzoxazine Catalysts at Room Temperature

Catalytic Depolymerization of Lignin in Supercritical Ethanol

Oxidative Depolymerisation of Lignosulphonate Lignin into Low-Molecular-Weight Products with Cu–Mn/δ-Al2O3

Yield and distribution of products of lignin liquefaction catalyzed by molybdenum-vanadium-phosphorus heteropolyacids

Lignin C-C Bond's Cleavage by Vanadium Catalyzed with High Selectivity in Acid Environment