Electrochemical Technology Applied In Treatment Of Wastewater And Groundwater
Chuanping Feng,Miao Li,Xu Guo,Chao Zhao,Zhenya Zhang,Norio Sugiura
2010-01-01
Abstract:The electrochemical method is an attractive alternative to other methods of wastewater treatment because of its environmental respectability and ease of operation. This study introduces the application of the electrochemical method for treatment of domestic and industrial wastewater.Electrochemical degradation of phenol was evaluated at two typical anodes, Ti/RuO2-Pt and Ti/IrO2-Pt, as a treatment method in toxic aromatic compounds discharged by chemical plants, petroleum refineries and pharmaceutical factories. According to the results, the electrochemical process for effective removal of phenol and ammonium was achieved in the presence of NaCl, in which phenol could be readily mineralized. For electrochemical reduction of nitrate, the Cu-Zn alloy cathode and the Ti/IrO2-Pt anode were used in an undivided cell. The Cu-Zn alloy cathode has a significant capacity of electrochemical reduction of nitrate. Under the conditions of 10mA/cm(2), addition of 500 mg/L NaCl and the parallel connection, the nitrate-N decreased from 50.0 mg/L to 9.8 mg/L for the 240-min electrolysis. Neither ammonia-N nor nitrite-N was detected at the end of electrolysis.Moreover, a series of experiments were performed with two types of practical electrochemical treatment systems (treatment capacities of 4m(3)/hr and 0.5m(3)/hr) using effluents from an anaerobic digester (EAD) of cattle wastewater, supernatants from primary sedimentation in a sewage plant (SPS) and domestic wastewater to evaluate the systems' treatment abilities. As a result, for both EAD and SPS, the 4 m(3)/hr system was found to remove 87 to 91% of T-P, 74 to 96% of T-N, 70 to 94% of NH4-N, 88 to 91% of TOC and 75 to 87% of COD. Similarly, the 0.5 m(3)/hr system was able to remove 62 to 90% of T-P, 83 to 92% of T-N, 90 to 100% of NH4-N, 75to 83% of TOC and 80 to 100% of COD. On the other hand, a pilot plant of an electrochemical treatment system (0.3 m(3)/hr) was successfully developed by treating domestic wastewater, pond water containing algae and wastewater from hog raising, in which electrocogulation and electrooxidation processes were used. In this system, the removal of T-N, T-P, NH4-N and COD from domestic wastewater and pond water containing algae was approximately 90%, while the removal of chlorophyll-a (chl-a) of algae was approximately 100%.