Abstract:This article demonstrates how to simultaneously utilize three degrees of modulation freedom, e.g. switching state selection (SSS), zero-sequence signal injection (ZSI) and redundant level modulation (RLM) to enable the voltage balancing in certain multilevel topologies, such as the presented five-level (5L), hybrid-clamped (HC) converter topologies, 5L-HC-E and 5L-HC-2E, as reference examples. Phase opposition disposition (POD), is another degree of modulation freedom used for the common-mode voltage (CMV) mitigation. The proposed control scheme is developed for the two most challenging 5L-HC device-reduced high-voltage topologies, which cannot be balanced with traditional modulation freedoms because voltage balance of one capacitor would worsen the balance of other capacitors. Only full utilization of degrees of modulation freedom with higher control ability can solve the balancing problem. A comprehensive explanation of these four control degrees of freedom is presented in this article. Power loss analysis is also provided with high modulation index and power factor. The proposed closed-loop control method can be easily implemented in a digital controller without requiring any mandatory proportional-integral (PI) controllers, since it only relies on closed-form analytical models and basic logic operators. The effectiveness of the control method has been verified in simulation and experiments covering the range of full modulation indexes (0-1.15), full power factors (0-1), various fundamental frequencies (5-50Hz), unequal load and capacitor degradation.

Hybrid Modulation Concept for Five-Level Active-Neutral-Point-Clamped Converter

Space Vector Modulation for SiC & Si Hybrid Active Neutral Point Clamped Converter

Structural Design of A Five-Level Hybrid Active Npc Converter for High Power Density Motor Drives

A Novel Single-Stage Five-Level Common-Ground-Boost-Type Active Neutral-Point-Clamped (5L-CGBT-ANPC) Inverter

A New Five-Level Hybrid-Clamped Converter with Reduced Number of Clamping Devices

Novel Five-Level Three-Phase Hybrid-Clamped Converter with Reduced Components

A Novel SVPWM Algorithm for Five-Level Active Neutral-Point-Clamped Converter

An Optimized Carrier-Based PWM Method and Voltage Balancing Control for Five-Level ANPC Converters

Hybrid Active Modulation Strategy for Three-Level Neutral-Point-Clamped Converters in High-Speed Aerospace Drives

Two Variations of Five-Level Hybrid-Clamped Converters and Their Voltage Balancing Control Using Three Degrees of Freedom

A New Modulation Method for a Five-Level Hybrid-Clamped Inverter with Reduced Flying Capacitor Size

An Active Virtual Space Vector Modulation Scheme for Three‐Level Neutral‐Point‐Clamped Converters

Generalized Low Switching Frequency Modulation for Neutral-Point-Clamped and Flying-Capacitor Four-Level Converters

Topology and Control of a Five-Level Hybrid-Clamped Converter for Medium-Voltage High-Power Conversions

Loss Distribution Analysis of Three-Level Active Neutral-Point-Clamped (3L-Anpc) Converter with Different Pwm Strategies

Full Utilization of the Four Degrees of Freedom in the Modulation and Control for Five-Level Hybrid-Clamped Converters

Active Modulation Strategy for Capacitor Voltage Balancing of Three-Level Neutral-Point-Clamped Converters in High-Speed Drives

Capacitor voltage balancing of five-level ANPC converter based on zero-sequence voltage injection using PS-PWM

Generalized Construction Method and Phase-Disposition PWM for SiC & Si Hybrid Multilevel Active-Neutral-Point-Clamped Converter

Capacitor Voltage Balancing of a Five-Level ANPC Converter Using Phase-Shifted PWM

An Advanced Modulation Technique Featuring Neutral Point Voltage Ripple Suppression of Three-Level Converters in High-Speed Drives