Abstract:Direct numerical simulations (DNS) of an upward heated pipe flow of supercritical CO2 (at Re0=3600) were carried out with and without conjugate heat transfer (CHT). The aim is to identify the impact of CHT on this specific flow problem and provide information for relevant numerical studies. The configuration is referred to one of the experiments carried out by Luo (2014), with a stainless steel (SS 304) pipe and a thermal activity ratio of 0.061. When CHT is introduced, the predictions of heat transfer coefficient (HTC) and wall temperature obtained in DNS are slightly improved against the experiment measurements. Two primary factors arise when CHT is considered, which are the axial redistribution of wall heat flux and the damping of the enthalpy fluctuations. The former affects the heat transfer particularly within a short distance after the inlet, leading to a more rapid establishment of the thermal boundary layer and a more rapidly progressing ‘laminarising’ process. The latter introduces substantial differences in the fluctuations of enthalpy (∼30 times difference) and density (∼40 times difference), which is however confined within a small region close to the wall and diminishes rapidly further away, resulting in a minor effect on turbulence and heat transfer in the main flow. When CHT is omitted, turbulent kinetic energy is over-predicted up to 1.55 times at most, in particular when the flow is being ‘laminarised’ (z/D<30). This is attributed to the discrepancies in shear production rather than the buoyancy production of the turbulent kinetic energy. Additionally, CHT alters both the laminar (Nul) and turbulent contributions (Nut) to the Nusselt number, with Nul starting at a lower level close to the inlet and the peak of Nut being reduced by 12.3%. These findings provide an insight on the impact of CHT on turbulence and heat transfer at different stages and valuable information for a more accurate modelling method for supercritical fluid flows.

Buoyancy effects on turbulent heat transfer of supercritical CO2 in a vertical mini-tube based on continuous wall temperature measurements

Reference temperature correction and dimensionless number analysis for heat transfer of supercritical CO2 in horizontal tubes

Convection Heat Transfer of Co2 at Supercritical Pressures in A Vertical Mini Tube

Convection heat transfer of supercritical pressure carbon dioxide in a vertical micro tube from transition to turbulent flow regime

Experimental research on the turbulent convection heat transfer of supercritical pressure CO 2 in a serpentine vertical mini tube

Investigation of Buoyancy-Enhanced Heat Transfer of Supercritical CO2 in Upward and Downward Tube Flows

Investigation of Flow Boiling Heat Transfer Characteristics of CO2in Horizontal Mini-Tube

Experimental Investigation on Cooling Heat Transfer and Buoyancy Effect of Supercritical Carbon Dioxide in Horizontal and Vertical Micro-Channels

Impact of Conjugate Heat Transfer on the Turbulence and Heat Transfer in an Upward Heated Pipe Flow at Supercritical Pressure

A Computational Study of Convection Heat Transfer to CO2 at Supercritical Pressures in a Vertical Mini Tube

Direct Numerical Simulation of Convective Heat Transfer of Supercritical Pressure in a Vertical Tube with Buoyancy and Thermal Acceleration Effects

Buoyancy Effects on Supercritical-Pressure Conjugate Heat Transfer of Aviation Kerosene in Horizontal Tubes

Flow and Heat Transfer Instability of Supercritical Carbon Dioxide in a Vertical Heated Tube

Numerical Study on the Gravity Effect on Heat Transfer of Supercritical CO2 in a Vertical Tube

Comprehensive evaluation on the thermal-hydraulic performance of supercritical CO2/R41 in a micro-fin tube

Numerical Investigation of Heat Transfer Characteristics of scCO2 Flowing in a Vertically-Upward Tube with High Mass Flux

Experimental Investigation of Convection Heat Transfer of CO2 at Super-Critical Pressures in Vertical Mini-Tubes and in Porous Media

Experimental study on heat transfer deterioration of supercritical CO2 in a round tube:A boundary assessment

Heat Transfer Characteristics of CO2 in a Horizontal Tube under Subcritical and Supercritical Pressures

Experimental and Numerical Study of Convection Heat Transfer of Co2 at Supercritical Pressures in Vertical Porous Tubes